Removal of motor oil by continuous multistage froth flotation: Effect of operational parameters

被引：4

作者：

Kanokkarn, P. ^{[1
]}

Shiina, T. ^{[2
,3
]}

Suttikul, T. ^{[4
]}

Chavadej, S. ^{[1
,5
]}

机构：

[1] Chulalongkorn Univ, Petr & Petrochem Coll, Bangkok, Thailand

[2] Chiba Univ, Grad Sch Hort, Fac Hort, Chiba, Japan

[3] Natl Agr & Food Res Org, Natl Food Res Inst, Ibaraki, Japan

[4] King Mongkuts Univ Technol North Bangkok, Fac Engn & Technol, Div Chem Proc Engn Technol, Rayong Campus, Rayong, Thailand

[5] Chulalongkorn Univ, Ctr Excellence Petrochem & Mat Technol, Bangkok, Thailand

来源：

SEPARATION SCIENCE AND TECHNOLOGY | 2016年 / 51卷 / 11期

关键词：

Multistage froth flotation; motor oil removal; extended surfactant; WASTE-WATER TREATMENT; LOW INTERFACIAL-TENSION; PHASE MICROEMULSION FORMATION; DYNAMIC SURFACE-TENSION; SODIUM DODECYL-SULFATE; AIR-FLOW RATE; FOAM FRACTIONATION; ETHYLBENZENE REMOVAL; EQUILIBRATION TIME; PART I;

D O I：

10.1080/01496395.2016.1187171

中图分类号：

O6 [化学];

学科分类号：

0703 ;

摘要：

A continuous multistage froth flotation column was employed to remove motor oil from water at a low concentration (500 mg/L) using an extended surfactant - branched alcohol propoxylate sulphate sodium salt (C14-15-8PO-SO4-Na) - as a frother. The highest separation efficiency (97% motor oil removal with the enrichment ratio of 16 for motor oil) was obtained at a foam height of 60 cm, an air flow rate of 40 L/min, a feed flow rate of 60 mL/min, a surfactant concentration of 0.3% (w/v), and an NaCl concentration of 1.5% (w/v). The process performance increased with increasing tray number but beyond 4 trays, the system could only offer lower concentrations of motor oil and surfactant in the effluent.

引用

页码：1847 / 1861

页数：15

共 50 条

[31] Removal of methylene blue by electrocoagulation: a study of the effect of operational parameters and mechanism
Ningning Liu
Yunhai Wu
[J]. Ionics, 2019, 25 : 3953 - 3960
[32] Effect of straggling parameters in the separation of oil in wastewater: Application in flotation columns.
Tavera, FJ
Escudero, R
[J]. AFINIDAD, 2003, 60 (508) : 516 - 524
[33] Effect of micro-bubble size and dynamic characteristics on oil removal efficiency of the flotation
Xie, Jun
Liu, Liansheng
Huo, Xinpeng
Liu, Qi
Liu, Xuanchen
Duan, Runze
[J]. SEPARATION AND PURIFICATION TECHNOLOGY, 2024, 337
[34] Effect of Operational Parameters on the Removal of Carbamazepine and Nutrients in a Submerged Ceramic Membrane Bioreactor
Dao, Khanh-Chau
Yang, Chih-Chi
Chen, Ku-Fan
Tsai, Yung-Pin
[J]. MEMBRANES, 2022, 12 (04)
[35] Effect of some operational parameters on the arsenic removal by electrocoagulation using iron electrodes
Can, Berrin Zeliha
Boncukcuoglu, Recep
Yilmaz, Alper Erdem
Fil, Baybars Ali
[J]. JOURNAL OF ENVIRONMENTAL HEALTH SCIENCE AND ENGINEERING, 2014, 12
[36] Electro-Fenton method for the removal of Malachite Green: effect of operational parameters
Teymori, Maryam
Khorsandi, Hassan
Aghapour, Ali Ahmad
Jafari, Seyed Javad
Maleki, Ramin
[J]. APPLIED WATER SCIENCE, 2020, 10 (01)
[37] Effect of operational parameters and material properties on hardness removal efficiency by electrochemical technique
Wang, Wei
Chen, Qi
Lin, Wei
Zheng, Xiaotao
Xu, Jianmin
Yu, Jiuyang
[J]. WATER SUPPLY, 2021, 21 (07) : 3437 - 3448
[38] Electro-Fenton method for the removal of Malachite Green: effect of operational parameters
Maryam Teymori
Hassan Khorsandi
Ali Ahmad Aghapour
Seyed Javad Jafari
Ramin Maleki
[J]. Applied Water Science, 2020, 10
[39] Effect of some operational parameters on the arsenic removal by electrocoagulation using iron electrodes
Berrin Zeliha Can
Recep Boncukcuoglu
Alper Erdem Yilmaz
Baybars Ali Fil
[J]. Journal of Environmental Health Science and Engineering, 12
[40] Studying interactive effects of operational parameters on continuous bipolar electrocoagulation–flotation process for treatment of high-load compost leachate
T. Amani
K. Veysi
W. Dastyar
Sh. Elyasi
[J]. International Journal of Environmental Science and Technology, 2015, 12 : 2467 - 2474

← 1 2 3 4 5 →