The Oxide-Scale Growth and Failure on an Fe-16Cr Alloy in the Presence of Compressive Stress

被引：6
|
作者：
Zhou, C. H. [1 ]
Liu, A. L. [1 ]
Ma, H. T. [2 ]
Wang, L. [2 ]
机构：
[1] Heilongjiang Univ Sci & Technol, Sch Mat Sci & Engn, Harbin 150022, Peoples R China
[2] Dalian Univ Technol, Sch Mat Sci & Engn, Dalian 116085, Peoples R China
来源：
OXIDATION OF METALS | 2016年 / 85卷 / 5-6期
基金：
中国国家自然科学基金;
关键词：
High temperature oxidation; Compressive stress; Kinetics; Failure; Fe-Cr alloy; FE-CR ALLOYS; INITIAL OXIDATION; BEHAVIOR; STEEL; ADHERENCE; TENSILE; NI;
D O I：
10.1007/s11085-016-9611-6
中图分类号：
TF [冶金工业];
学科分类号：
0806 ;
摘要：
The high temperature oxidation behavior of an Fe-16Cr binary alloy, oxidized under different compressive stresses in air at 900 degrees C, was investigated. Surface and cross-sectional micrographs, observed by scanning electron microscopy, indicated that the resulting morphology of the thermally grown oxide scale depended on the compressive stress. Results showed that oxide scales were infact below 5 MPa stress after 10 h of oxidation. Delamination developed at the outer/inner oxide scale interface in the case of compressive stress above 5 MPa. Growth kinetics measurements revealed that the rate of oxide-scale growth increased by the compressive stress.
引用
收藏
页码：537 / 546
页数：10
相关论文
共 50 条
  • [21] The mechanical property of the oxide scale on Fe-Cr alloy steels
    Yang, Chan-Woo
    Kim, Jung-Hoon
    Triambulo, Ross E.
    Kang, Youn-Hee
    Lee, Jong-Sub
    Park, Jin-Woo
    JOURNAL OF ALLOYS AND COMPOUNDS, 2013, 549 : 6 - 10
  • [22] Influences of Yttrium on Adhesion of Oxide Scale of Fe-Cr-Al Alloy
    辛丽
    李美栓
    周龙江
    王福会
    李铁藩
    JournalofRareEarths, 2001, (02) : 117 - 121
  • [23] Influences of yttrium on adhesion of oxide scale of Fe-Cr-Al alloy
    Xin, L
    Li, MS
    Zhou, LJ
    Wang, FH
    Li, TF
    JOURNAL OF RARE EARTHS, 2001, 19 (02) : 117 - 121
  • [24] Effect of Electric Current on Growth of Oxide Scale on Fe-25Cr Alloy for SOFC Interconnect at 1073 K
    Kawamura, K.
    Nitobe, T.
    Kurokawa, H.
    Ueda, M.
    Maruyama, T.
    JOURNAL OF THE ELECTROCHEMICAL SOCIETY, 2012, 159 (03) : B259 - B264
  • [25] Imaging of mass transports around the oxide scale/Fe-Cr alloy interfaces
    Horita, T
    Xiong, YP
    Yamaji, K
    Kishimoto, H
    Sakai, N
    Brito, ME
    Yokokawa, H
    SOLID STATE IONICS, 2004, 174 (1-4) : 41 - 48
  • [26] Effect of grain boundaries on the formation of oxide scale in Fe-Cr alloy for SOFCs
    Horita, Teruhisa
    Kishimoto, Haruo
    Yamaji, Katsuhiko
    Xiong, Yueping
    Sakai, Natsuko
    Bri'to, Manuel E.
    Yokokawa, Harumi
    SOLID STATE IONICS, 2008, 179 (27-32) : 1320 - 1324
  • [27] OXIDE SCALE INDUCED CLEAVAGE FRACTURE OF AN ODS FE-CR-AL ALLOY
    DAVIDSON, JM
    AUSTIN, CM
    ROBINSON, ML
    JOURNAL OF METALS, 1982, 35 (12): : A90 - A90
  • [28] OXIDE SCALE INDUCED CLEAVAGE FRACTURE IN AN ODS FE-CR-AL ALLOY
    DAVIDSON, JM
    AUSTIN, CM
    ROBINSON, ML
    METALLURGICAL TRANSACTIONS A-PHYSICAL METALLURGY AND MATERIALS SCIENCE, 1983, 14 (07): : 1516 - 1518
  • [29] Effect of perovskite coating on oxide scale growth on Fe-22Cr
    Persson, A.
    Hendriksen, P. V.
    Mikkelsen, L.
    Somers, M. A. J.
    DIFFUSION IN SOLIDS AND LIQUIDS: MASS DIFFUSION, 2006, 258-260 : 372 - +
  • [30] RELATION BETWEEN IMPURITIES AND OXIDE-SCALE GROWTH MECHANISMS ON NI-34CR AND NI-20CR ALLOYS .2. INFLUENCE OF SULFUR
    BENABDERRAZIK, G
    MOULIN, G
    HUNTZ, AM
    OXIDATION OF METALS, 1990, 33 (3-4): : 237 - 264
12345