Corrosion resistance of HVOF-sprayed Ni2Si intermetallic coatings in hot H2SO4 medium

被引：6
|
作者：
Verdian, M. M. [1 ]
Raeissi, K. [1 ]
Salehi, M. [1 ]
机构：
[1] Isfahan Univ Technol, Dept Mat Engn, Esfahan 8415683111, Iran
来源：
SURFACE & COATINGS TECHNOLOGY | 2014年 / 240卷
关键词：
Corrosion; EIS; Mott-Schottky; H2SO4; Ni2Si; HVOF; STEEL;
D O I：
10.1016/j.surfcoat.2013.12.016
中图分类号：
TB3 [工程材料学];
学科分类号：
0805 ; 080502 ;
摘要：
Corrosion behavior of high velocity oxy-fuel (HVOF) Ni2Si intermetallic coatings was investigated by means of Tafel polarization tests and electrochemical impedance spectroscopy (EIS) measurements in 70% H2SO4 solutions at 75 degrees C. Mott-Schottky analysis was also carried out to investigate semiconductive properties of passive films. It was found that the corrosion rate of HVOF Ni2Si coating was much lower than that of stainless steel substrate. Both Ni2Si bulk and coating materials showed an active-passive behavior with a wide passive range during anodic polarization. EIS measurements at open circuit conditions revealed that the system showed one time constant at low frequencies which was attributed to charge transfer processes. Under passive conditions, one time constant was observed at high frequencies which was related to formation of passive films. Further investigation showed that passive film formed on Ni2Si materials in H2SO4 is a p-type semiconductor with acceptor density in the order of 1020 cm(-3). (C) 2013 Elsevier B.V. All rights reserved.
引用
收藏
页码：70 / 75
页数：6
相关论文
共 50 条
  • [21] Corrosion and electrochemical behavior of Ni-P coatings in 0.5 m H2SO4
    Petukhov, IV
    Shcherban', MG
    Skryabina, NE
    Malinina, LN
    PROTECTION OF METALS, 2002, 38 (04): : 370 - 376
  • [22] Effect of sulphide concentration on corrosion behaviors of HVOF-sprayed WC-Cr3C2-Ni and WC-Ni coatings
    Wei, Ziyu
    Cui, Dandong
    Wei, Zheng
    Hong, Sheng
    INTERNATIONAL JOURNAL OF REFRACTORY METALS & HARD MATERIALS, 2023, 111
  • [23] CORROSION OF LEAD BY H2SO4
    FONTANA, MG
    INDUSTRIAL AND ENGINEERING CHEMISTRY, 1951, 43 (09): : A105 - A106
  • [24] CORROSION OF STEEL BY H2SO4
    FONTANA, MG
    INDUSTRIAL AND ENGINEERING CHEMISTRY, 1951, 43 (08): : A65 - &
  • [25] Hot corrosion behavior of HVOF-sprayed Cr3C2-WC-NiCoCrMo coating
    Zhou, Wuxi
    Zhou, Kesong
    Deng, Chunming
    Zeng, Keli
    Li, Yuxi
    CERAMICS INTERNATIONAL, 2017, 43 (12) : 9390 - 9400
  • [26] Microstructure and properties of HVOF-sprayed WC-(W,Cr)2C-Ni coatings
    Berger, Lutz-Michael
    Saaro, Sabine
    Naumann, Tobias
    Kasparova, Michaela
    Zahalka, Frantisek
    JOURNAL OF THERMAL SPRAY TECHNOLOGY, 2008, 17 (03) : 395 - 403
  • [27] Microstructure and Properties of HVOF-Sprayed WC-(W,Cr)2C-Ni Coatings
    Lutz-Michael Berger
    Sabine Saaro
    Tobias Naumann
    Michaela Kašparova
    František Zahálka
    Journal of Thermal Spray Technology, 2008, 17 : 395 - 403
  • [28] Effects of Heat Treatment on the Structures and Wear Behaviors of HVOF-Sprayed Ni-MoS2 Coatings
    Hwang, Jiun-Ren
    Liu, Yu-Liang
    Chang, Chia-Hua
    Jeng, Ming-Chang
    MATERIALS TRANSACTIONS, 2020, 61 (09) : 1813 - 1819
  • [29] Corrosion Behavior of Nitrided Ni3Al Intermetallic Alloy in 0.5 M H2SO4
    Tapia-Bahena, E.
    Martinez, H.
    Porcayo-Calderon, I
    Gonzalez-Rodriguez, J. G.
    Martinez-Gomez, L.
    INTERNATIONAL JOURNAL OF ELECTROCHEMICAL SCIENCE, 2018, 13 (11): : 11323 - 11334
  • [30] CORROSION OF NI-MO-CR ALLOY BY H2SO4
    FONTANA, MG
    INDUSTRIAL AND ENGINEERING CHEMISTRY, 1951, 43 (11): : A113 - &
12345