Flash sintering with concurrent crystallization of Li1.5Al0.5Ge1.5(PO4)3 glass

被引：12
|
作者：
Campos, Joao, V [1 ,2 ,3 ]
Lavagnini, Isabela R. [4 ,5 ]
Zallocco, Vinicius M. [1 ,2 ,3 ]
Ferreira, Eduardo B. [3 ,6 ]
Pallone, Eliria M. J. A. [4 ,5 ]
Rodrigues, Ana C. M. [2 ,3 ]
机构：
[1] Univ Fed Sao Carlos, Mat Sci & Engn Grad Program, BR-13565905 Sao Carlos, SP, Brazil
[2] Univ Fed Sao Carlos, Dept Mat Engn, BR-13635905 Sao Carlos, SP, Brazil
[3] Univ Fed Sao Carlos, FAPESP, LaMaV, DEMa,Ctr Res Technol & Educ Vitreous Mat CeRTEV, BR-13565905 Sao Carlos, SP, Brazil
[4] Univ Sao Paulo, Dept Biosyst Engn, Ave Duque de Caxias Norte 225, BR-13635900 Pirassununga, SP, Brazil
[5] Univ Sao Paulo, Mat Sci & Engn Grad Program, FZEA, Ave Duque de Caxias Norte 225, BR-13635900 Pirassununga, Brazil
[6] Univ Sao Paulo, Sao Carlos Sch Engn, Dept Mat Engn, BR-13566590 Sao Carlos, SP, Brazil
来源：
ACTA MATERIALIA | 2023年 / 244卷
基金：
巴西圣保罗研究基金会;
关键词：
LAGP; NaSICON; Solid-state electrolyte; Reactive flash sintering; Glass-ceramic; LIME SILICATE GLASS; TEMPERATURE DISTRIBUTION; IONIC-CONDUCTIVITY; ZNO CERAMICS; MICROSTRUCTURE; ZIRCONIA; DENSITY; FIELD;
D O I：
10.1016/j.actamat.2022.118593
中图分类号：
T [工业技术];
学科分类号：
08 ;
摘要：
Single-phase Li1.5Al0.5Ge1.5(PO4)3 NaSICON (Na superionic conductor) glass-ceramic is obtained via a new route using flash-sinter crystallization. Green compacts of glass powder are sinter-crystallized in a few seconds. The results suggest that controlling the current increase during the flash event is needed to avoid overheating, which could cause the melting of the samples. A processing map for the flash sinter-crystallization of Li1.5Al0.5-Ge1.5(PO4)3 is developed and presented based on the current density and holding time at the steady state. The samples fabricated by flash sinter-crystallization are compared with those conventionally heated. Using this novel technique, single-phase glass-ceramics are obtained with total ionic conductivity at room temperature surpassing that of glass-ceramics prepared by conventional heating (2.26 10-4 S cm-1 and 1.36 10-4 S cm- 1, respectively).
引用
收藏
页数：10
相关论文
共 50 条
  • [21] Sol-gel synthesis of Li1.5Al0.5Ge1.5(PO4)3 solid electrolyte
    Kotobuki, Masashi
    Koishi, Masaki
    CERAMICS INTERNATIONAL, 2015, 41 (07) : 8562 - 8567
  • [22] Lithium storage capability of lithium ion conductor Li1.5Al0.5Ge1.5(PO4)3
    Feng, J. K.
    Lu, L.
    Lai, M. O.
    JOURNAL OF ALLOYS AND COMPOUNDS, 2010, 501 (02) : 255 - 258
  • [23] Preparation of the Li1.5Al0.5Ge1.5(PO4)3 solid electrolyte with high ionic conductivity
    Kunshina G.B.
    Bocharova I.V.
    Ivanenko V.I.
    Inorganic Materials: Applied Research, 2017, 8 (02) : 238 - 244
  • [24] Improvement of Li1.5Al0.5Ge1.5(PO4)3 (LAGP) superionic conductivity via antimony doping
    Lebedeva, Maria
    Markov, Viktor
    Kim, Artem
    Chernyavsky, Vladislav
    Olkhovskii, Denis
    Vishniakov, Pavel
    Maximov, Maxim
    IONICS, 2025, 31 (01) : 239 - 247
  • [25] In operando Raman microscopy of the Cu/Li1.5Al0.5Ge1.5(PO4)3 solid electrolyte interphase
    Weich, Ineke
    Dopilka, Andrew
    Kasnatscheew, Johannes
    Winter, Martin
    Kostecki, Robert
    CHEMICAL COMMUNICATIONS, 2025, 61 (07) : 1459 - 1462
  • [26] Synthesis, structural investigations and properties of Si-modified Li1.5Al0.5Ge1.5(PO4)3 glass-ceramics
    Pershina, S. V.
    Kuznetsova, E. S.
    Belyakov, S. A.
    Elterman, V. A.
    Abdurakhimova, R. K.
    Voronin, V. I.
    Starostin, G. N.
    SOLID STATE IONICS, 2024, 405
  • [27] Influence of B2O3 addition on the ionic conductivity of Li1.5Al0.5Ge1.5(PO4)3 glass ceramics
    Jadhav, Harsharaj S.
    Cho, Min-Seung
    Kalubarme, Ramchandra S.
    Lee, Jong-Sook
    Jung, Kyu-Nam
    Shin, Kyoung-Hee
    Park, Chan-Jin
    JOURNAL OF POWER SOURCES, 2013, 241 : 502 - 508
  • [28] Increase in grain boundary ionic conductivity of Li1.5Al0.5Ge1.5(PO4)3 by adding excess lithium
    Chung, Habin
    Kang, Byoungwoo
    SOLID STATE IONICS, 2014, 263 : 125 - 130
  • [29] The Preparation of Li1.5Al0.5Ge1.5(PO4)3 Glass-Ceramics with Lithium-Ion Conductivity from an Oxalate Precursor
    G. B. Kunshina
    I. V. Bocharova
    Glass Physics and Chemistry, 2020, 46 : 576 - 583
  • [30] Preparation of Li1.5Al0.5Ge1.5(PO4)3 solid electrolytes via the co-precipitation method
    Kotobuki, Masashi
    Koishi, Masaki
    JOURNAL OF ASIAN CERAMIC SOCIETIES, 2019, 7 (04) : 551 - 557
12345