Simulation and experimental of refuse derived fuel pyrolysis based on aspen plus

被引：0
|
作者：
Li, Yan-Ji [1 ,2 ]
Jiang, Lu [1 ]
Zou, Ke-Wei [1 ]
Zhao, Ning [1 ]
Li, Yu-Long [1 ]
Li, Run-Dong [1 ]
Chi, Yong [2 ]
机构：
[1] Clean Energy Key Laboratory of Liaoning, Shenyang Aerospace University, Shenyang 110136, China
[2] State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, China
来源：
Zhejiang Daxue Xuebao (Gongxue Ban)/Journal of Zhejiang University (Engineering Science) | 2013年 / 47卷 / 09期
关键词：
Gas chromatography - Gases - Computer software - Volume fraction - Pyrolysis;
D O I：
10.3785/j.issn.1008-973X.2013.09.019
中图分类号：
学科分类号：
摘要：
Conducted a simulation to the pyrolysis process of refuse derived fuel (RDF) based on chemical simulation software aspen plus firstly and established the pyrolysis reaction model to obtain the pyrolysis yields of RDF products and the volume fractions of pyrolysis gases. Then the pyrolysis experiment of RDF was conducted in a high-temperature tube furnace and the volume fractions of pyrolysis gases were measured by using gas chromatographic analyzer. By comparing the simulation values with experimental values, it is concluded that: the yields of pyrolysis liquid and gas increase with the increase of final pyrolysis temperature, but the yield of semi-coke decreases, while the H2 volume fraction increases but the CO2 volume fraction decreases; Compared to the RDF added waste lime, the RDF added sludge lower productivities of pyrolysis liquid and char, whereas has higher productivity of pyrolysis gas; the CO2 volume fraction reduces with the decrease of biomass content; moreover, the volume fraction of CO2 from the RDF added sludge is lower than that from the RDF added waste lime.
引用
收藏
页码：1637 / 1643
相关论文
共 50 条
  • [41] Two stages catalytic pyrolysis of refuse derived fuel: Production of biofuel via syncrude
    Miskolczi, N.
    Buyong, F.
    Angyal, A.
    Williams, P. T.
    Bartha, L.
    BIORESOURCE TECHNOLOGY, 2010, 101 (22) : 8881 - 8890
  • [42] Reactivity in oxygen and carbon dioxide of char formed in the pyrolysis of refuse-derived fuel
    Cozzani, V
    INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH, 2000, 39 (04) : 864 - 872
  • [43] Features of Refuse Derived Fuel in Poland-Physicochemical Properties and Availability of Refuse Derived Fuel
    Nowak, Martyna
    JOURNAL OF ECOLOGICAL ENGINEERING, 2023, 24 (03): : 1 - 9
  • [44] Pyrolysis and gasification studies of model refuse derived fuel (RDF) using thermogravimetric analysis
    Aluri, Sireesha
    Syed, Akil
    Flick, Derrick W.
    Muzzy, John D.
    Sievers, Carsten
    Agrawal, Pradeep K.
    FUEL PROCESSING TECHNOLOGY, 2018, 179 : 154 - 166
  • [45] Synergistic pyrolysis with Refuse-Derived Fuel (RDF) can neutralize bauxite residue
    Seno Júnior R.
    Veloso M.C.R.D.A.
    Moreno R.A.
    Yamaji F.M.
    Process Safety and Environmental Protection, 2024, 189 : 1103 - 1111
  • [46] Effect of heat transfer model on the prediction of refuse-derived fuel pyrolysis process
    Zhou, Chunguang
    Yang, Weihong
    FUEL, 2015, 142 : 46 - 57
  • [47] Pellet characteristics and pyrolysis products of ultrasonic-assisted refuse-derived fuel
    Liu, Hongyu
    Tang, Yuting
    Ding, Sichun
    Yue, Wenchang
    Zheng, Xuerong
    Ma, Xiaoqian
    BIOMASS CONVERSION AND BIOREFINERY, 2022, 14 (21) : 27595 - 27607
  • [48] Refuse Derived Fuel (RDF) production and gasification in a pilot plant integrated with an Otto cycle ICE through Aspen plus™ modelling: Thermodynamic and economic viability
    Lozano Nasner, Albany Milena
    Silva Lora, Electo Eduardo
    Escobar Palacio, Jose Carlos
    Rocha, Mateus Henrique
    Restrepo, Julian Camilo
    Venturini, Osvaldo Jose
    Ratner, Albert
    WASTE MANAGEMENT, 2017, 69 : 187 - 201
  • [49] Aspen Plus Simulation of Bio-Char Production from a Biomass-Based Slow Pyrolysis Process
    Dahawi Y.A.
    Abdulrazik A.
    Abu Seman M.N.
    Abd Aziz M.A.
    Mohd Yunus M.Y.
    Key Engineering Materials, 2019, 797 : 336 - 341
  • [50] A Study on the Simulation of Biomass Chemical Looping Gasification Coupled with CO2Pyrolysis Based on Aspen Plus
    Feng, Yipeng
    Wei, Guoqiang
    Huang, Zhen
    Zheng, Anqing
    Su, Tongchao
    Zhang, Mingming
    Shiyou Xuebao, Shiyou Jiagong/Acta Petrolei Sinica (Petroleum Processing Section), 2022, 38 (06): : 1456 - 1466
12345