Simulation and experimental of refuse derived fuel pyrolysis based on aspen plus

被引：0
|
作者：
Li, Yan-Ji [1 ,2 ]
Jiang, Lu [1 ]
Zou, Ke-Wei [1 ]
Zhao, Ning [1 ]
Li, Yu-Long [1 ]
Li, Run-Dong [1 ]
Chi, Yong [2 ]
机构：
[1] Clean Energy Key Laboratory of Liaoning, Shenyang Aerospace University, Shenyang 110136, China
[2] State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, China
来源：
Zhejiang Daxue Xuebao (Gongxue Ban)/Journal of Zhejiang University (Engineering Science) | 2013年 / 47卷 / 09期
关键词：
Gas chromatography - Gases - Computer software - Volume fraction - Pyrolysis;
D O I：
10.3785/j.issn.1008-973X.2013.09.019
中图分类号：
学科分类号：
摘要：
Conducted a simulation to the pyrolysis process of refuse derived fuel (RDF) based on chemical simulation software aspen plus firstly and established the pyrolysis reaction model to obtain the pyrolysis yields of RDF products and the volume fractions of pyrolysis gases. Then the pyrolysis experiment of RDF was conducted in a high-temperature tube furnace and the volume fractions of pyrolysis gases were measured by using gas chromatographic analyzer. By comparing the simulation values with experimental values, it is concluded that: the yields of pyrolysis liquid and gas increase with the increase of final pyrolysis temperature, but the yield of semi-coke decreases, while the H2 volume fraction increases but the CO2 volume fraction decreases; Compared to the RDF added waste lime, the RDF added sludge lower productivities of pyrolysis liquid and char, whereas has higher productivity of pyrolysis gas; the CO2 volume fraction reduces with the decrease of biomass content; moreover, the volume fraction of CO2 from the RDF added sludge is lower than that from the RDF added waste lime.
引用
收藏
页码：1637 / 1643
相关论文
共 50 条
  • [31] Refuse derived fuels pyrolysis
    Casu, S
    Galvagno, S
    Calabrese, A
    Casciaro, G
    Martino, M
    Russo, A
    Portofino, S
    JOURNAL OF THERMAL ANALYSIS AND CALORIMETRY, 2005, 80 (02) : 477 - 482
  • [32] Refuse derived fuel carbonization technology and application of carbonized refuse derived fuel
    Shiotsu, Koichi
    Yamada, Sumio
    Yoshida, Tetsuo
    2002, Kawasaki Steel Corporation
  • [33] Pyrolysis and combustion kinetics of refuse derived fuel having different plastic ratio
    Tripathi, Priyanka
    Rao, Lakshminarayana
    BIORESOURCE TECHNOLOGY REPORTS, 2023, 23
  • [34] GASIFICATION OF REFUSE DERIVED FUEL IN A PAIRED FLUIDIZED BED PYROLYSIS UNIT.
    Suzuki, S.
    Yakowitz, H.
    1600,
  • [35] Pyrolysis Experiment of Refuse Derived Fuel and Study on Characteristics of Semi-coke
    Li, Yanji
    Zou, Kewei
    Zhao, Ning
    Li, Rundong
    Chi, Yong
    CONSTRUCTION AND URBAN PLANNING, PTS 1-4, 2013, 671-674 : 2626 - +
  • [36] Primary fragmentation behavior of refuse derived fuel pellets during rapid pyrolysis
    Zaini, Ilman Nuran
    Wen, Yuming
    Mousa, Elsayed
    Jonsson, Par Goran
    Yang, Weihong
    FUEL PROCESSING TECHNOLOGY, 2021, 216
  • [37] Experimental investigation on an explosion accident from refuse derived fuel
    Fu, ZM
    Koseki, H
    Li, XR
    PROGRESS IN SAFETY SCIENCE AND TECHNOLOGY, VOL 4, PTS A and B, 2004, 4 : 1047 - 1052
  • [38] REFUSE DERIVED FUEL IN THE NETHERLANDS
    BOESMANS, B
    CONSERVATION & RECYCLING, 1986, 9 (01): : 23 - 28
  • [39] Pyrolysis gas characteristics of refuse derived fuel from high heating value waste based on source separation
    Li, Yanji
    Zou, Kewei
    Zhao, Ning
    Li, Rundong
    Chi, Yong
    Cen, Kefa
    Chi, Y. (chiyong@zju.edu.cn), 1600, Central South University of Technology (45): : 2078 - 2084
  • [40] Pyrolysis of biomass and refuse-derived fuel performance in laboratory scale batch reactor
    Kluska, Jacek
    Klein, Marek
    Kazimierski, Pawel
    Kardas, Dariusz
    ARCHIVES OF THERMODYNAMICS, 2014, 35 (01) : 141 - 152
12345