Intrinsic reaction rate and the effects of operating conditions in dimethyl ether synthesis from methanol dehydration

被引：0
|
作者：
Gholamreza Moradi
Fereydoon Yaripour
Hossein Abbasian
Mostefa Rahmanzadeh
机构：
[1] Razi University,Catalyst Research Center, Department of Chemical Engineering, Faculty of Engineering
[2] Petrochemical Research & Technology Company NPC,Catalysis Research group, Tehran Center
来源：
Korean Journal of Chemical Engineering | 2010年 / 27卷
关键词：
Kinetic; Methanol Dehydration; Dimethyl Ether; Experiment Design;
D O I：
暂无
中图分类号：
学科分类号：
摘要：
The kinetic behavior of a commercial γ-Al2O3 catalyst for the methanol to dimethyl ether (DME) dehydration reaction has been investigated using a differential fixed bed reactor at the pressure range 1–16 barg within a temperature range of 260–380 °C. The experimental runs were performed in a wide range of feed to water ratios. The experiments were designed by general full factorial design (GEFD) and a novel rate equation has been developed which exhibited the best fitting with our experimental data. Based on the analysis of variance (ANOVA), the following order of importance for operating conditions was obtained when the objective function is the yield of DME: Temperature >Water % in feed >Pressure. In addition, the optimum operating conditions for the maximum yield of DME, were found at T= 380°C, P=16 barg and zero wt% of water in the feed.
引用
收藏
页码：1435 / 1440
页数：5
相关论文
共 50 条
  • [1] Intrinsic reaction rate and the effects of operating conditions in dimethyl ether synthesis from methanol dehydration
    Moradi, Gholamreza
    Yaripour, Fereydoon
    Abbasian, Hossein
    Rahmanzadeh, Mostefa
    KOREAN JOURNAL OF CHEMICAL ENGINEERING, 2010, 27 (05) : 1435 - 1440
  • [2] Direct dimethyl ether synthesis from synthesis gas: The influence of methanol dehydration on methanol synthesis reaction
    Dadgar, Farbod
    Myrstad, Rune
    Pfeifer, Peter
    Holmen, Anders
    Venvik, Hilde J.
    CATALYSIS TODAY, 2016, 270 : 76 - 84
  • [3] Direct dimethyl ether synthesis from synthesis gas: The influence of methanol dehydration on methanol synthesis reaction
    Dadgar, Farbod
    Myrstad, Rune
    Pfeifer, Peter
    Holmen, Anders
    Venvik, Hilde
    ABSTRACTS OF PAPERS OF THE AMERICAN CHEMICAL SOCIETY, 2015, 249
  • [4] DEHYDRATION CATALYSTS FOR THE METHANOL DIMETHYL ETHER REACTION
    SPIVEY, JJ
    CHEMICAL ENGINEERING COMMUNICATIONS, 1991, 110 : 123 - 142
  • [5] Effects of Reaction Conditions on Methanol Produced to Dimethyl Ether
    Liu, S.
    Zhang, L.
    ENERGY SOURCES PART A-RECOVERY UTILIZATION AND ENVIRONMENTAL EFFECTS, 2015, 37 (18) : 1937 - 1942
  • [6] Kinetics of the reaction of olefin synthesis from methanol and dimethyl ether
    Pisarenko, E. V.
    Pisarenko, V. N.
    THEORETICAL FOUNDATIONS OF CHEMICAL ENGINEERING, 2008, 42 (06) : 822 - 831
  • [7] Kinetics of the reaction of olefin synthesis from methanol and dimethyl ether
    E. V. Pisarenko
    V. N. Pisarenko
    Theoretical Foundations of Chemical Engineering, 2008, 42
  • [8] Statistical analysis of reaction rate data of liquid phase synthesis of dimethyl ether from methanol
    Gogate, Makarand R.
    Midha, Chand
    Lee, Sungyyu
    Fuel Science and Technology International, 1993, 11 (09): : 1251 - 1268
  • [9] Direct synthesis of dimethyl ether from carbon-monoxide-rich synthesis gas: Influence of dehydration catalysts and operating conditions
    Stiefel, Miriam
    Ahmad, Ruaa
    Arnold, Ulrich
    Doering, Manfred
    FUEL PROCESSING TECHNOLOGY, 2011, 92 (08) : 1466 - 1474
  • [10] Synthesis and Catalytic Property of a Zeolite Composite for Preparation of Dimethyl Ether from Methanol Dehydration
    Jiajun Zheng
    Jinghong Ma
    Yan Wang
    Yadong Bai
    Xiwen Zhang
    Ruifeng Li
    Catalysis Letters, 2009, 130 : 672 - 678
12345