Kinetics and Mechanism of Decarburization and Melting of Direct-Reduced Iron Pellets in Slag

被引:0
|
作者
Jianghua Li
Mansoor Barati
机构
[1] University of Toronto,Department of Materials Science and Engineering
[2] AK Steel Corporation,undefined
来源
Metallurgical and Materials Transactions B | 2009年 / 40卷
关键词
Decarburization; Slag Composition; Slag Phase; Slag Viscosity; Decarburization Rate;
D O I
暂无
中图分类号
学科分类号
摘要
An experimental study was conducted to understand the decarburization and melting behavior of direct-reduced iron (DRI) pellets in SiO2-Al2O3-CaO-MgO-FeO slags with various FeO concentrations (10 to 25 wt pct) and basicities (Bs), ranging from 1.5 to 2.5. The behavior of the pellet in slag was observed using the X-ray fluoroscopy technique; the rate of decarburization was simultaneously measured with a constant volume pressure increase technique. The study shows that the decarburization of DRI in slag at 1600 °C takes place in two stages. The first stage is the reaction between the FeO and the carbon inside the pellet, which is controlled by heat transfer from the slag to the pellet; the second stage involves the decarburization reaction between the FeO in the slag and the remaining carbon in the DRI. The kinetics of this stage is determined by the mass transfer of FeO in the slag and is strongly dependent on the FeO concentration. Depending on the physicochemical properties of the slag and the rate of gas evolution, the DRI may sink through, float inside the slag, or remain on top before complete decarburization.
引用
收藏
页码:17 / 24
页数:7
相关论文
共 50 条
  • [31] Kinetics and mechanism of reduction in composite iron ore - Reductant pellets
    Ghosh, A
    ICARISM '99: PROCEEDINGS OF THE INTERNATIONAL CONFERENCE ON ALTERNATIVE ROUTES OF IRON AND STEELMAKING, 1999, 99 (03): : 71 - 78
  • [32] Kinetics and mechanism of reduction of iron ore pellets under load
    Nasr, MI
    El-Geassy, AA
    Halim, KSA
    61ST IRONMAKING CONFERENCE PROCEEDINGS, 2002, 61 : 597 - 620
  • [33] KINETICS OF DECARBURIZATION OF LOW-CARBON LIQUID-IRON UNDER REDUCED PRESSURES
    HARASHIMA, K
    MIZOGUCHI, S
    KAJIOKA, H
    TETSU TO HAGANE-JOURNAL OF THE IRON AND STEEL INSTITUTE OF JAPAN, 1988, 74 (03): : 449 - 456
  • [34] KINETICS OF DECARBURIZATION OF LOW-CARBON LIQUID-IRON UNDER REDUCED PRESSURES
    HARASHIMA, K
    MIZOGUCHI, S
    KAJIOKA, H
    TRANSACTIONS OF THE IRON AND STEEL INSTITUTE OF JAPAN, 1988, 28 (04) : 335 - 335
  • [35] CARBURIZATION AND MELTING MECHANISM OF REDUCED IRON-ORE
    TSUKIHASHI, F
    SOMA, T
    TRANSACTIONS OF THE IRON AND STEEL INSTITUTE OF JAPAN, 1982, 22 (02) : B9 - B9
  • [36] KINETICS OF DECARBURIZATION OF LOW-CARBON LIQUID-IRON UNDER REDUCED PRESSURES
    HARASHIMA, K
    TETSU TO HAGANE-JOURNAL OF THE IRON AND STEEL INSTITUTE OF JAPAN, 1987, 73 (04): : S226 - S226
  • [37] KINETICS OF DECARBURIZATION OF LOW-CARBON LIQUID-IRON UNDER REDUCED PRESSURE
    HARASHIMA, K
    MIZOGUCHI, S
    KAJIOKA, H
    CHIDA, H
    TRANSACTIONS OF THE IRON AND STEEL INSTITUTE OF JAPAN, 1987, 27 (09) : B224 - B224
  • [38] Erosion and corrosion mechanisms in pneumatic conveying of direct reduced iron pellets
    Univ. Autonoma de Nuevo Leon, FIME, A.P. 74F, 66450 San Nicolás, N.L., Mexico
    不详
    ASTM Spec Tech Publ, 1362 (137-149):
  • [39] ON THE REOXIDATION BEHAVIOR OF DIRECT REDUCED IRON PELLETS IN AIR AT MODERATE TEMPERATURES
    MEDINA, JO
    FOSTER, JS
    CIM BULLETIN, 1982, 75 (842): : 112 - 112
  • [40] Erosion and corrosion mechanisms in pneumatic conveying of direct reduced iron pellets
    Pérez-Unzueta, AJ
    Martínez, D
    Flores, MA
    Arroyave, R
    Velasco, A
    Viramontes, R
    WEAR PROCESSES IN MANUFACTURING, 1998, 1362 : 137 - 149