Preliminary Technical and Economic Analysis of Alkali and Low Temperature Thermo-alkali Pretreatments for the Anaerobic Digestion of Waste Activated Sludge

Waste activated sludge (WAS) contains various organic and inorganic substances that should be treated for a safe disposal. Anaerobic digestion is the most widely accepted method for stabilizing WAS. This work presents preliminary results concerning the technical and economic feasibility of alkali and hybrid thermo-alkali pretreatments for the improvement of WAS anaerobic digestion. Chemicals used for pretreatments were NaOH and Ca(OH)(2), with doses in the range of 0.04-0.2 g alkali/g TS. The same substances were used for hybrid pretreatments at low temperature (70 and 90 A degrees C). Test outcomes demonstrated that NaOH was a more performing chemical in sludge disintegration and COD liberation than Ca(OH)(2). NaOH showed good performances already at low doses (0.08 g NaOH/g TS) with disintegration rates in the order of 20 %. Thermal effect improved alkali performance, in fact the biogas yield increased of 13.2 and 26.8 % when samples were treated respectively at 20 and 70 A degrees C with 0.04 g NaOH/g TS for 90 min. However, until nowadays economic issues (mainly the cost of chemicals for alkali pretreatments and pH conditioning) have limited the real-world applications of alkali and hybrid pretreatments. The preliminary economic analysis performed in this work demonstrated that, if the pretreatment was carried out with a dose of alkali of 0.08 g NaOH/g TS, only an increase in the methane yield in the order of 60 % could offset the cost of chemicals. On the other hand, if the alkali dose was of only 0.04 g NaOH/g TS, increases in the methane yields in the order of 15-20 % were sufficient.