Use of glycerol by-product of biodiesel to produce an efficient dust suppressant

被引：85

作者：

Medeiros, Miguel A. ^{[1
]}

Leite, Carla M. M. ^{[2
]}

Lago, Rochel M. ^{[2
]}

机构：

[1] Univ Fed Tocantins, Dept Ciencias Biol, BR-77500000 Porto Nacl, TO, Brazil

[2] Univ Fed Minas Gerais, Dept Quim, Inst Ciencias Exatas, BR-31270901 Belo Horizonte, MG, Brazil

来源：

CHEMICAL ENGINEERING JOURNAL | 2012年 / 180卷

关键词：

Glycerol; Biodiesel; Polymerization; Dust suppressor; Environment; MESOPOROUS CATALYSTS; OLIGOMERIZATION; ETHERIFICATION;

D O I：

10.1016/j.cej.2011.11.056

中图分类号：

X [环境科学、安全科学];

学科分类号：

08 ; 0830 ;

摘要：

In this work, glycerol oligomerization to produce dust suppressants in the presence of acids (H2SO4 or H2SO4) and basic (NaOH) catalysts was investigated. The obtained results showed that kind of catalyst and its concentration are critical to obtain good yield for olygomers, as verified by Thermogravimetric Analysis. Under optimized condition it was possible to obtain reaction solutions with viscosity greater than 160 times that of glycerol and good suppressive action of dust, with only molar rate of 3% H2SO4, 140 degrees C/1 h. Since using crude glycerol derived from biodiesel production and 380 degrees C, was obtained hexa and heptaglycerol, in 3 h (verified by ESI-MS). Tests for dust suppression performance with the product derived from crude glycerol showed higher efficiency of material, when compared to products of oligomerization of glycerol and a commercial product. (C) 2011 Elsevier B.V. All rights reserved.

引用

页码：364 / 369

页数：6

共 50 条

[21] Optimization of compost fermentation of glycerol by-product discharged from biodiesel fuel production process
Sadano, Yuta
Toshimitsu, Ryota
Kohda, Jiro
Nakano, Yasuhisa
Yano, Takuo
[J]. JOURNAL OF MATERIAL CYCLES AND WASTE MANAGEMENT, 2010, 12 (04) : 308 - 313
[22] Optimization of compost fermentation of glycerol by-product discharged from biodiesel fuel production process
Yuta Sadano
Ryota Toshimitsu
Jiro Kohda
Yasuhisa Nakano
Takuo Yano
[J]. Journal of Material Cycles and Waste Management, 2010, 12 : 308 - 313
[23] Use of the Glycerin By-Product From Biodiesel Production for Power Generation
Pickett, Derek
Depcik, Christopher
Stagg-Williams, Susan
[J]. JOURNAL OF ENGINEERING FOR GAS TURBINES AND POWER-TRANSACTIONS OF THE ASME, 2018, 140 (10):
[24] Growth Kinetics of Polyhydroxyalkanoates Production by Ralstonia eutropha with Crude Glycerol from Biodiesel By-Product
Kongruang, Sasithorn
[J]. PROCEEDINGS OF THE 2010 INTERNATIONAL CONFERENCE ON ENVIRONMENTAL SCIENCE AND TECHNOLOGY (ICEST 2010), 2010, : 271 - 275
[25] Conversion of Biodiesel By-Product Glycerol to Fuel Ethers over Different Solid Acid Catalysts
Ozbay, Nalan
Oktar, Nuray
Dogu, Gulsen
Dogu, Timur
[J]. INTERNATIONAL JOURNAL OF CHEMICAL REACTOR ENGINEERING, 2010, 8
[26] Organic Carbonate Production Utilizing Crude Glycerol Derived as By-Product of Biodiesel Production: A Review
Nomanbhay, Saifuddin
Ong, Mei Yin
Chew, Kit Wayne
Show, Pau-Loke
Lam, Man Kee
Chen, Wei-Hsin
[J]. ENERGIES, 2020, 13 (06)
[27] A low-cost synthesis of biodiesel at room temperature and purification of by-product glycerol for reuse
Yogesh C. Sharma
Bhaskar Singh
Shweta Agrawal
[J]. Biomass Conversion and Biorefinery, 2012, 2 (1) : 63 - 71
[28] Enzymatic Synthesis of Poly(glycerol sebacate) Pre-polymer with Crude Glycerol, by-product from Biodiesel Prodution
Godinho, Bruno
Gama, Nuno
Barros-Timmons, Ana
Ferreira, Artur
[J]. 9TH INTERNATIONAL CONFERENCE ON TIMES OF POLYMERS AND COMPOSITES: FROM AEROSPACE TO NANOTECHNOLOGY, 2018, 1981
[29] An Efficient CaO-Based Catalyst for Rapid Production of Biodiesel without Glycerol as a by-Product Using a Tri-Component Reaction
Tang, Ying
Li, Shaoying
Dong, Jianlong
Meng, Mei
Zhang, Jie
[J]. JOURNAL OF THE AMERICAN OIL CHEMISTS SOCIETY, 2018, 95 (12) : 1487 - 1496
[30] Using Glycerin, a By-Product of Biodiesel, as a Grinding Aid in the Dry Grinding of Marble Dust Waste
Katırcıoğlu-Bayel D.
[J]. Scientific Mining Journal, 2023, 62 (02): : 61 - 66

← 1 2 3 4 5 →