SUBCOOLED BOILING IN THE ULTRASONIC FIELD (ON CAUSE OF MEB GENERATION)

被引：0
|
作者：
Inagaki, Fumio [1 ]
Suzuki, Koichi [1 ]
Hong, Chungpyo [1 ]
机构：
[1] Tokyo Univ Sci, Sch Mech Engn, Chiba 2788510, Japan
来源：
ICNMM 2009, PTS A-B | 2009年
关键词：
HEAT-TRANSFER;
D O I：
暂无
中图分类号：
TH [机械、仪表工业];
学科分类号：
0802 ;
摘要：
Subcooled quasi-pool boiling for water, ethanol aqueous solutions of 10wt% and 50wt% and ethanol in ultrasonic field is performed for the upward flat heating surface of copper block with 10mm in diameter under the atmospheric condition. Tested liquid subcooling is 15K, 20K and 25K for water and aqueous solutions of ethanol and 20K, 30K and 40K for 100wt% ethanol. At 20K of liquid subcooling for water and ethanol aqueous solutions, no microbubble emission boiling (MEB) has been observed in quasi-pool boiling. Even if MEB occurred, the heat flux does not increase and it turns easily to film boiling. In ultrasonic field, MEB occurs remarkably and the heat flux increases higher than the ordinary critical heat flux as observed in highly subcooled boiling. The experimental results show that the ultrasonic vibration introduces the instability of interface of liquid and vapor and accelerate MEB at 20K of liquid subcooling for water and aqueous solutions of ethanol. At 15K of liquid subcooling for water and aqueous solutions, no effect of ultrasonic vibration is observed. At 25K of liquid subcooling, the ultrasonic vibration extends MEB region to higher superheat of heating surface for aqueous solutions of ethanol. The maximum heat flux in MEB decreases with increasing of ethanol concentration and becomes CHF for 100wt% ethanol. No effect of ultrasonic vibration on boiling is observed for the 100wt% ethanol in the present experiments.
引用
收藏
页码：37 / 42
页数：6
相关论文
共 50 条
  • [41] A study on transition process to MEB by limiting boiling space
    Kawakami, Kendai
    Sakamoto, Shosuke
    Tanigawa, Hirofumi
    Tsuruta, Takaharu
    JOURNAL OF THERMAL SCIENCE AND TECHNOLOGY, 2021, 16 (01) : 1 - 11
  • [42] Film boiling of subcooled liquids. Part II: Steady regimes of subcooled liquids film boiling
    Yagov, V. V.
    Leksin, M. A.
    Zabirov, A. R.
    Denisov, M. A.
    INTERNATIONAL JOURNAL OF HEAT AND MASS TRANSFER, 2016, 100 : 918 - 926
  • [43] Modeling of Boiling of Subcooled Water and Ethanol under Conditions of Pulsed Heat Generation in a Wall
    Pokusaev, B. G.
    Nekrasov, D. A.
    Tairov, E. A.
    HIGH TEMPERATURE, 2012, 50 (01) : 84 - 90
  • [44] VOID FRACTION IN SUBCOOLED BOILING-PREDICTION OF INITIAL POINT OF NET VAPOR GENERATION
    STAUB, FW
    MECHANICAL ENGINEERING, 1967, 89 (10) : 71 - &
  • [45] Modeling of boiling of subcooled water and ethanol under conditions of pulsed heat generation in a wall
    B. G. Pokusaev
    D. A. Nekrasov
    E. A. Tairov
    High Temperature, 2012, 50 : 84 - 90
  • [46] Prediction of onset of nucleate boiling, net vapour generation and subcooled CHF in coiled tubes
    Jayanti, S.
    Hewitt, G.F.
    Warme- und Stoffubertragung Zeitschrift, 1991, 26 (06): : 301 - 305
  • [47] APPLICATION OF GENERATION AND CONDENSATION MODELS TO PREDICT SUBCOOLED BOILING VOID AT LOW-PRESSURES
    CHATOORGOON, V
    DIMMICK, GR
    CARVER, MB
    SELANDER, WN
    SHOUKRI, M
    NUCLEAR TECHNOLOGY, 1992, 98 (03) : 366 - 378
  • [48] The effect of evaporation and condensation in vapor bubbles on the hydrodynamic sound generation in a subcooled boiling liquid
    B. M. Dorofeev
    V. I. Volkova
    Acoustical Physics, 2006, 52 : 173 - 179
  • [49] PREDICTION OF ONSET OF NUCLEATE BOILING, NET VAPOR GENERATION AND SUBCOOLED CHF IN COILED TUBES
    JAYANTI, S
    HEWITT, GF
    WARME UND STOFFUBERTRAGUNG-THERMO AND FLUID DYNAMICS, 1991, 26 (06): : 301 - 305
  • [50] ADDITIONAL DATA ON SUBCOOLED BOILING OF HEPTANE
    MULLERSTEINHAGEN, H
    JOURNAL OF HEAT TRANSFER-TRANSACTIONS OF THE ASME, 1987, 109 (04): : 1057 - 1058
12345