Influence of two-stage air supply on behavior of kerosene combustion and NOx emission in porous ceramic burner

被引:1
|
作者
Takami, H [1 ]
Noda, N
Itaya, Y
Matsuda, H
Hasatani, M
机构
[1] Nagoya Univ, Dept Energy Engn & Sci, Nagoya, Aichi 4648603, Japan
[2] Nagoya Univ, Dept Chem Engn, Nagoya, Aichi 4648603, Japan
[3] Nagoya Univ, Res Ctr Adv Waste & Emiss Management, Nagoya, Aichi 4648603, Japan
关键词
porous ceramic burner; kerosene; NOx emission; two-stage air supply;
D O I
10.1252/kakoronbunshu.24.476
中图分类号
TQ [化学工业];
学科分类号
0817 ;
摘要
A porous ceramic burner has already been proposed for high turn down ratio in kerosene combustion. However, at higher loads, considerable amounts of NOx are found to be emitted. This present paper proposes a two-stage air supply system for reducing NOx emitted from kerosene combustion on a porous ceramic burner, and other combustion characteristic of this burner are experimentally studied. It has been confirmed from experimental works that by introducing two-stage air supply the fuel lean limit is lowered to as low as 0.2 equivalence ratio and that the stable combustion area ranges from 2.0 to 11.5 kW. Then the corresponding turn down ratio achieves 5.8. Since the ratio of primary air to total air greatly influences not only the temperature distribution in the burner but also the soot formation, the CO concentration and the NOx emission at the exit of the burner, this value is regarded as an important operating factor in this burner. By using the optimum ratio of primary air to total air, the NOx emission is found to be approximately one-quarter to that of the emission with single-stage air supply.
引用
收藏
页码:476 / 480
页数:5
相关论文
共 50 条
  • [31] A two-stage multiobjective optimization algorithm for porous air bearing design
    Wang, Nenzi
    Chen, Hsin-Yi
    TRIBOLOGY INTERNATIONAL, 2016, 93 : 355 - 363
  • [32] Study on nonpremixed methane/air combustion from flame structure and NOX emission aspect for different burner head structures
    Buyukakin, Mustafa Kemalettin
    Oztuna, Semiha
    INTERNATIONAL JOURNAL OF ENERGY RESEARCH, 2019, 43 (10) : 5421 - 5437
  • [33] Influence of air ratio on combustion and NOx emission characteristics of pulverized coal industrial boiler
    Yan, Rong
    Chen, Zhichao
    Yuan, Linxuan
    Zhang, Bo
    Li, Xin
    Li, Zhengqi
    COMBUSTION SCIENCE AND TECHNOLOGY, 2023, 195 (12) : 2972 - 2984
  • [34] Combustion Characteristics and Emission of a Two-Stroke Compression Ignition Engine with Two-Stage Injection
    宋军
    吕兴才
    李孝禄
    黄震
    JournalofShanghaiJiaotongUniversity, 2007, (01) : 53 - 60
  • [35] Combustion characteristics and emission of a two-stroke compression ignition engine with two-stage injection
    Song, Jun
    Lu, Xing-Cai
    Li, Xiao-Lu
    Huang, Zhen
    Journal of Shanghai Jiaotong University (Science), 2007, 12 E (01) : 53 - 60
  • [36] Analysis of combustion pressure effects on nitrogen oxide emission by gas turbine combustion chambers with a two-stage combustion process
    Ricken, V
    Leuckel, W
    COMBUSTION AND INCINERATION, 1999, 1492 : 429 - 434
  • [37] Numerical Investigation on Combustion and Emission of a Diesel Engine using Two-stage Injection Strategy
    Yu, Hanzhengnan
    Liang, Xingyu
    Wang, Yuesen
    Zhang, Hongsheng
    8TH INTERNATIONAL CONFERENCE ON APPLIED ENERGY (ICAE2016), 2017, 105 : 1344 - 1349
  • [38] NOx-Reduction by Applying Two-Stage Combustion: Experiments on an Industrial Tubular Water Boiler.
    Broer, Willem T.
    Schalke, Pieter
    de Weert, Geert
    1600, (117):
  • [39] Laminar Flame Characteristics of Sequential Two-Stage Combustion of Premixed Methane/Air Flames
    Duva, Berk Can
    Wang, Yen-Cheng
    Chance, Lauren Elizabeth
    Toulson, Elisa
    JOURNAL OF ENGINEERING FOR GAS TURBINES AND POWER-TRANSACTIONS OF THE ASME, 2021, 143 (06):
  • [40] LAMINAR FLAME CHARACTERISTICS OF SEQUENTIAL TWO-STAGE COMBUSTION OF PREMIXED METHANE/AIR FLAMES
    Duva, Berk Can
    Wang, Yen-Cheng
    Chance, Lauren Elizabeth
    Toulson, Elisa
    PROCEEDINGS OF THE ASME TURBO EXPO 2020: TURBOMACHINERY TECHNICAL CONFERENCE AND EXHIBITION, VOL 4A, 2020,