Experimental Study on Combustion Characteristics of Grease Attached on Oxygen Cylinder in High-pressure Oxygen

被引：0

作者：

Zeng Guohui ^{[1
]}

Zhang Lijing ^{[1
]}

Tao Gang ^{[1
]}

Zhang Liang ^{[2
]}

机构：

[1] Nanjing Univ Technol, Coll Urban Construct & Safety Engn, Nanjing, Jiangsu, Peoples R China

[2] Minist Housing & Urban, Technol & Ind Dev Ctr, Beijing, Peoples R China

来源：

2013 INTERNATIONAL CONFERENCE ON PROCESS EQUIPMENT, MECHATRONICS ENGINEERING AND MATERIAL SCIENCE | 2013年 / 331卷

关键词：

oxygenation process; lubricating oil; oxidation; ignition point; burning rate; Pressurized Thermogravimetry (PTG);

D O I：

10.4028/www.scientific.net/AMM.331.591

中图分类号：

TM [电工技术]; TN [电子技术、通信技术];

学科分类号：

0808 ; 0809 ;

摘要：

The possible reasons of an explosion during the process of filling oxygen cylinder were analyzed in this article. And finding the grease in the cylinder may be the main cause of this incident. Using three kinds of lubricating oil as the experimental grease were experimented in combustion reaction under different pressure of oxygen by PTG. The relationship between the increment of lubricating oils' mass, ignition point, combustion rate and the pressure of oxygen were derived from the TG and DTG curve (TG-DTG curve). Experimental results show that the oil oxidation increment increase and the ignition point decrease with the pressure of oxygen escalating, and the higher pressure of oxygen, the lower combustion rate. In addition, the fact was confirmed that the lubricants additives have an effect on combustion characteristics of lubricating oil in high-pressure oxygen.

引用

页码：591 / +

页数：2

共 50 条

[41] PERFORMANCE-CHARACTERISTICS OF A HIGH-PRESSURE PULSED SINGLET OXYGEN GENERATOR
ENDO, M
KODAMA, K
HANDA, Y
UCHIYAMA, T
JOURNAL OF APPLIED PHYSICS, 1992, 71 (12) : 5760 - 5767
[42] An Experimental Study on High Temperature and Low Oxygen Air Combustion
W.B. Kim
D.H. Chung
J.B. Yang
D.S. Noh Korea Institute of Energy Research
Journal of Thermal Science, 2000, (02) : 169 - 175
[43] An experimental study on high temperature and low oxygen air combustion
Chung, DH
Yang, JB
Noh, DS
Kim, WB
KOREAN JOURNAL OF CHEMICAL ENGINEERING, 1999, 16 (04) : 489 - 493
[44] HIGH PRESSURE COMBUSTION IN OXYGEN DIFFUSION FLAMES .V. OXYGEN EFFECTS FUEL RATIO AND OXYGEN PRESSURE ON COMBUSTION RATE
ZUKOCKER, HM
BRENNSTOFF-CHEMIE, 1968, 49 (05): : 141 - &
[45] PERFORMANCE TESTING IN OXYGEN OF A HIGH-PRESSURE, HIGH-VOLUME OXYGEN COMPRESSOR
TESSIER, MJ
GRANGER, RA
MECHANICAL ENGINEERING, 1983, 105 (11) : 104 - 104
[46] Experimental Study on Oxygen-enriched Combustion Characteristics of Pure Cotton
Meng, Haiyu
Wang, Shuzhong
Chen, Lin
Zhao, Jun
Wu, Zhiqiang
APPLIED ENERGY TECHNOLOGY, PTS 1 AND 2, 2013, 724-725 : 253 - 256
[47] Simulation of high-pressure methane-oxygen combustion with a new reduced chemical mechanism
Monnier, Florian
Ribert, Guillaume
COMBUSTION AND FLAME, 2022, 235
[48] Study of high-pressure catalytic combustion
Department of Aeronautics and Astronautics, National Cheng Kung University, No.1, Ta-Hsueh Road, Tainan 701, Taiwan
不详
Hangkong Taikong ji Minhang Xuekan, 2006, 1 (1-8):
[49] Study on spray combustion of hydrogen-oxygen in a high pressure chamber
Khaleghi, H.
Tabejammat, S.
COMBUSTION SCIENCE AND TECHNOLOGY, 2007, 179 (1-2) : 343 - 354
[50] BIOCHEMICAL EFFECTS OF OXYGEN AT HIGH-PRESSURE IN RATS
BANISTER, EW
DAVISON, AJ
BHAKTHAN, NM
ASMUNDSON, C
CANADIAN JOURNAL OF PHYSIOLOGY AND PHARMACOLOGY, 1973, 51 (09) : 673 - 678

← 1 2 3 4 5 →