Load Emulation with Independent Metering for a Pump Test Bench

被引：0

作者：

Pfizenmaier, Max ^{[1
]}

Pippes, Thomas ^{[2
]}

Bohr, Artur ^{[2
]}

Falkenstein, Jens ^{[1
]}

机构：

[1] Univ Rostock, Fac Mech Engn & Marine Engn, Dept Transmiss & Drive Technol, Justus von Liebig Weg 6, D-18059 Rostock, Germany

[2] Hydraul Nord Technol GmbH, Ludwigsluster Chaussee 5, D-19370 Parchim, Germany

来源：

ACTUATORS | 2023年 / 12卷 / 11期

关键词：

test bench; four-quadrant pump; pressure control; independent metering;

D O I：

10.3390/act12110413

中图分类号：

TH [机械、仪表工业];

学科分类号：

0802 ;

摘要：

For the investigation of new types of internal gear pumps under realistic conditions, a test bench is presented that enables dynamic load emulation via the pressure with simultaneous dynamic speed control of the pump. For pressure control, a hydraulic half-bridge with separate control edges is used on both sides of the pump and a pressure control is presented. An error-based adaptive controller is used for pressure control and tested experimentally. It is shown that the error-based adaptive controller has a better performance compared to a simple PID control.

引用

页数：16

共 50 条

[1] Motor test bench control for load profile emulation
Taleires Filho, Jucelino
Correia, Wilkley Bezerra
Brandao Aguiar, Victor de Paula
The Pontes, Ricardo Silva
[J]. 45TH ANNUAL CONFERENCE OF THE IEEE INDUSTRIAL ELECTRONICS SOCIETY (IECON 2019), 2019, : 6663 - 6668
[2] EMULATION OF VEHICLE DYNAMICS ON AN ENGINE TEST BENCH
SHAFAI, E
GEERING, HP
[J]. PROCEEDINGS OF THE 1989 AMERICAN CONTROL CONFERENCE, VOLS 1-3, 1989, : 1969 - 1976
[3] Experimental test bench for analog fault emulation
Toczek, Wojciech
[J]. PRZEGLAD ELEKTROTECHNICZNY, 2011, 87 (10): : 136 - 139
[4] Design and modeling of hardware-in-loop test bench for hydraulic excavator based on dynamic load emulation
Chen, Jinshi
Huo, Dongyang
Liu, Changyi
Zhang, Han
Wang, Yuqi
[J]. AUTOMATION IN CONSTRUCTION, 2022, 137
[5] Control of a test bench for dynamic emulation of mechanical loads
Kyslan, Karol
Durovsky, Frantisek
[J]. MODELLING OF MECHANICAL AND MECHATRONICS SYSTEMS, 2012, 48 : 352 - 357
[6] PUMP UNIT DIAGNOSTIC AND TEST BENCH
Kostyukov, V. N.
Boichenko, S. N.
Kostyukov, A. V.
Kopelev, O. N.
Pavlov, A. A.
Shestov, A. G.
Tavolgin, A. Yu.
Shelestov, D. S.
[J]. CHEMICAL AND PETROLEUM ENGINEERING, 2014, 50 (3-4) : 262 - 267
[7] A Novel RLC Load Emulation for Anti-Islanding Test Bench for Inverter and Machine Based Distributed Generation
Narayanan, Nakul K.
Shan, S.
Umanand, L.
[J]. 2018 IEEE ENERGY CONVERSION CONGRESS AND EXPOSITION (ECCE), 2018, : 25 - 30
[8] Development of a laboratory test bench for the emulation of wave energy converters
Blanco, M.
Moreno-Torres, P.
Lafoz, M.
Beloqui, M.
Castiella, A.
[J]. 2015 IEEE INTERNATIONAL CONFERENCE ON INDUSTRIAL TECHNOLOGY (ICIT), 2015, : 2487 - 2492
[9] Electronic Unit Pump Test Bench Development and Pump Properties Research
刘波澜
黄英
张付军
赵长禄
[J]. Journal of Beijing Institute of Technology, 2006, (04) : 384 - 388
[10] Load Emulation Compensation Control of a Test Bench Based on Rigid-Flexible Coupling Transmission for a Vehicle Electric Drive System
Li, Haodi
Zhao, Zhiguo
Tang, Peng
[J]. IEEE TRANSACTIONS ON INSTRUMENTATION AND MEASUREMENT, 2022, 71

← 1 2 3 4 5 →