Microcontroller-Based Embedded System for the Diagnosis of Stator Winding Faults and Unbalanced Supply Voltage of the Induction Motors

被引:2
|
作者
Pietrzak, Przemyslaw [1 ]
Pietrzak, Piotr [1 ]
Wolkiewicz, Marcin [1 ]
机构
[1] Wroclaw Univ Sci & Technol, Dept Elect Machines Drives & Measurements, Wybrzeze Wyspianskiego 27, PL-50370 Wroclaw, Poland
关键词
induction motor drive; fault diagnosis; stator winding fault; supply voltage unbalance; ARM Cortex; embedded system;
D O I
10.3390/en17020387
中图分类号
TE [石油、天然气工业]; TK [能源与动力工程];
学科分类号
0807 ; 0820 ;
摘要
Induction motors (IMs) are one of the most widely used motor types in the industry due to their low cost, high reliability, and efficiency. Nevertheless, like other types of AC motors, they are prone to various faults. In this article, a low-cost embedded system based on a microcontroller with the ARM Cortex-M4 core is proposed for the extraction of stator winding faults (interturn short circuits) and an unbalanced supply voltage of the induction motor drive. The voltage induced in the measurement coil by the axial flux was used as a source of diagnostic information. The process of signal measurement, acquisition, and processing using a cost-optimized embedded system (NUCLEO-L476RG), with the potential for industrial deployment, is described in detail. In addition, the analysis of the possibility of distinguishing between interturn short circuits and unbalanced supply voltage was carried out. The effect of motor operating conditions and fault severity on the symptom extraction process was also studied. The results of the experimental research conducted on a 1.5 kW IM confirmed the effectiveness of the developed embedded system in the extraction of these types of faults.
引用
收藏
页数:22
相关论文
共 50 条
  • [31] Diagnosis of Stator Faults Severity in Induction Motors Using Two Intelligent Approaches
    Cunha Palacios, Rodrigo Henrique
    da Silva, Ivan Nunes
    Goedtel, Alessandro
    Godoy, Wagner Fontes
    Lopes, Tiago Drummond
    IEEE TRANSACTIONS ON INDUSTRIAL INFORMATICS, 2017, 13 (04) : 1681 - 1691
  • [32] Diagnosis of short-circuit faults in stator winding inside low-voltage induction motor using impulse voltage test
    Research and Development Division, TOENEC Corp., 1-79 Takiharu-cho, Minami-ku, Nagoya 457-0819, Japan
    IEEJ Trans. Ind Appl., 9 (915-921+8):
  • [33] Diagnosis of Short-Circuit Faults in Stator Winding Inside Low-Voltage Induction Motor Using Impulse Voltage Test
    Nakamura, Hisahide
    ELECTRICAL ENGINEERING IN JAPAN, 2015, 191 (03) : 32 - 39
  • [34] Design and analysis of an automatic voltage regulator microcontroller-based distributed power supply
    Wang, Xiumin
    Jiang, Liting
    Shan, Liang
    Li, Zhengquan
    Xiong, Rihui
    Xu, Jianbing
    International Journal of Smart Home, 2015, 9 (05): : 223 - 232
  • [35] On-line stator fault diagnosis in low voltage induction motors
    Albizu, I
    Zamora, I
    Mazón, AJ
    Saenz, JR
    Tapia, A
    UPEC 2004: 39TH INTERNATIONAL UNIVERSITITIES POWER ENGINEERING CONFERENCE, VOLS 1-3, CONFERENCE PROCEEDINGS, 2005, : 504 - 508
  • [36] Microcontroller-Based Embedded System Equipment Development for Research and Educational Support
    Vassiliev, A. E.
    Ivanova, T. Y.
    Tapia, D. F. Cabezas
    Luong, Q. Trinh
    2016 INTERNATIONAL CONFERENCE ON INFORMATION MANAGEMENT AND TECHNOLOGY (ICIMTECH), 2016, : 219 - 223
  • [37] Faults detection in stator windings of induction motors based on signal injection
    Otero, M.
    de la Barrera, P. M.
    Bossio, G. R.
    Leidhold, R.
    Tyshakin, O.
    2018 IEEE BIENNIAL CONGRESS OF ARGENTINA (ARGENCON), 2018,
  • [38] An Embedded Microcontroller-Based Access Authentication System of Wireless Sensor Network
    Liu, Weixue
    Journal of Cyber Security Technology, 2023, 7 (01) : 1 - 20
  • [39] Implementation of genetic algorithm in an embedded microcontroller-based polarization control system
    Mamdoohi, Ghazaleh
    Abas, Ahmad Fauzi
    Samsudin, Khairulmizam
    Ibrahim, Noor Hisham
    Hidayat, Ariya
    Mahdi, Mohd Adzir
    ENGINEERING APPLICATIONS OF ARTIFICIAL INTELLIGENCE, 2012, 25 (04) : 869 - 873
  • [40] A Microcontroller-Based Embedded System Design Course with PSoC3
    Sitik, Can
    Nagvajara, Prawat
    Taskin, Baris
    2013 IEEE INTERNATIONAL CONFERENCE ON MICROELECTRONIC SYSTEMS EDUCATION (MSE), 2013, : 28 - 31