Development of an integrated membrane condenser system with LNG cold energy for water recovery from humid flue gases in power plants

被引：8

作者：

Qaterji, Abdulmohsin M. ^{[1
]}

Salilih, Elias M. ^{[1
]}

Siddiqui, M. E. ^{[1
]}

Almatrafi, Eydhah ^{[2
,3
]}

Nurrohman, Nurrohman ^{[1
]}

Abulkhair, Hani ^{[1
,3
]}

Alsaiari, Abdulmohsen ^{[1
,3
]}

Macedonio, Francesca ^{[4
]}

Wang, Zhaohui ^{[5
]}

Albeirutty, Mohammad ^{[1
,3
]}

Drioli, Enrico ^{[4
]}

Cui, Zhaoliang ^{[5
]}

Bamaga, Omar ^{[3
]}

机构：

[1] King Abdulaziz Univ, Dept Mech Engn, POB 80204, Jeddah 21589, Saudi Arabia

[2] King Abdulaziz Univ, Fac Engn Rabigh, Dept Mech Engn, Jeddah 21589, Saudi Arabia

[3] King Abdulaziz Univ, Ctr Excellence Desalinat Technol, POB 80200, Jeddah 21589, Saudi Arabia

[4] Inst Membrane Technol CNR ITM, Via P Bucci 17-C, I-87036 Arcavacata Di Rende, CS, Italy

[5] Nanjing Tech Univ, Coll Chem Engn, State Key Lab Mat Oriented Chem Engn, Nanjing 211816, Peoples R China

来源：

INTERNATIONAL JOURNAL OF HYDROGEN ENERGY | 2023年 / 48卷 / 79期

关键词：

Membrane condenser; Thermodynamic analysis; Liquefied natural gas (LNG); LNG regasification Cold energy; LIQUEFIED NATURAL-GAS; HEAT-RECOVERY; OPTIMIZATION; PERFORMANCE; DESIGN;

D O I：

10.1016/j.ijhydene.2023.04.239

中图分类号：

O64 [物理化学（理论化学）、化学物理学];

学科分类号：

070304 ; 081704 ;

摘要：

This paper investigates a detailed thermodynamic analysis of a modular-type membrane condenser system where a cooler or condenser is connected in series upstream of the membrane condenser module. A coolant circulates inside the cooler/condenser to cool down the industrial flue gas up to saturation conditions. The analysis covers water recovery rate and energy requirement for different combinations of flue gas humidity, flow rate, and temperature. Additionally, a case study is included which considers a practical industrial exhaust flue gas where the constituents of the flue gas with volumetric ratio and the feed parameters are referred from the literature. The case study investigated the utilization of cold energy obtained by LNG regasification facility as a cooling power source for the water vapor recovery process. A detailed heat transfer analysis based on the heat exchanger model is performed to determine the required mass flow rate of cooling water and natural gas. It is concluded that, the water self-sufficiency of a power plant can be

引用

页码：30791 / 30803

页数：13

共 50 条

[41] A novel lignite pre-drying system integrated with flue gas waste heat recovery at lignite-fired power plants
Yan, Min
Ma, Chunyuan
Shen, Qiuwan
Song, Zhanlong
Chang, Jingcai
APPLIED THERMAL ENGINEERING, 2019, 150 : 200 - 209
[42] ENERGY REQUIREMENT OF A TWO-STAGE MEMBRANE SEPARATION UNIT OF CO2 FROM FLUE GASES OF THE POWER UNIT
Kotowicz, Janusz
Janusz-Szymanska, Katarzyna
RYNEK ENERGII, 2010, (06): : 56 - 61
[43] Thermodynamic analysis of KCS/ORC integrated power generation system with LNG cold energy exploitation and CO2 capture
Pan, Zhen
Zhang, Li
Zhang, Zhien
Shang, Liyan
Chen, Shujun
JOURNAL OF NATURAL GAS SCIENCE AND ENGINEERING, 2017, 46 : 188 - 198
[44] Revolutionizing energy: converting CO2 into methanol using flue gases from natural gas combined cycle power plants
Al-Elanjawy, Yasser Abbas Hammady
Yilmaz, Mustafa
SUSTAINABLE ENERGY & FUELS, 2025, 9 (03): : 833 - 846
[45] Energy, exergy and thermoeconomic analysis of a novel combined cooling and power system using low-temperature heat source and LNG cold energy recovery
Ghaebi, Hadi
Parikhani, Towhid
Rostamzadeh, Hadi
ENERGY CONVERSION AND MANAGEMENT, 2017, 150 : 678 - 692
[46] Design on a novel waste heat recovery system integrated with the bypass flue and outside primary air preheater for bitumite-fired power plants
Zhang, Guozhu
Zhang, Shunqi
Sun, Bo
Liu, Jiping
Yan, Junjie
ENERGY, 2024, 291
[47] Thermodynamic assessment of integrated heat recovery system combining exhaust-gas heat and cold energy for LNG regasification process in FSRU vessel
Sangick Lee
Byung Chul Choi
Journal of Mechanical Science and Technology, 2016, 30 : 1389 - 1398
[48] Thermodynamic assessment of integrated heat recovery system combining exhaust-gas heat and cold energy for LNG regasification process in FSRU vessel
Lee, Sangick
Choi, Byung Chul
JOURNAL OF MECHANICAL SCIENCE AND TECHNOLOGY, 2016, 30 (03) : 1389 - 1398
[49] Characteristic analysis and refrigerant optimization of an integrated system for LNG cryogenic energy recovery through power generation and seawater pre-desalination
Li, Zuqiang
Zhang, Xiao
Cai, Liang
THERMAL SCIENCE AND ENGINEERING PROGRESS, 2025, 59
[50] Development of energy saving technology for flue gas carbon dioxide recovery in power plant by chemical absorption method and steam system
Mimura, T
Simayoshi, H
Suda, T
Iijima, M
Mituoka, S
ENERGY CONVERSION AND MANAGEMENT, 1997, 38 : S57 - S62

← 1 2 3 4 5 →