Two-phase flow Investigation in a centrifugal rotor through particle image velocimetry

被引:0
|
作者
Ofuchi, E. M. [1 ]
Stel, H. [1 ]
Mancilla, E. [1 ,2 ]
Morales, R. E. M. [1 ]
机构
[1] Univ Tecnol Fed Parana, Multiphase Flow Res Ctr NUEM, Grad Program Mech & Mat Engn PPGEM, Curitiba, PR, Brazil
[2] Ctr Invest & Innovac Tecnol, Inst Tecnol Nuevo Leon, Nuevo Leon, Mexico
关键词
Centrifugal pump; Two-phase flow; PIV; Turbulence enhancement; Turbulence suppression; SUBMERSIBLE PUMP ESP; ENTRAINED AIR; HYDRAULIC PERFORMANCE; IMPELLER; VISUALIZATION; TURBULENCE; PATTERNS; DIFFUSER; PIV; CLEARANCE;
D O I
10.1016/j.ces.2025.121360
中图分类号
TQ [化学工业];
学科分类号
0817 ;
摘要
This work uses Particle Image Velocimetry (PIV) to calculate the liquid flow field in a radial centrifugal rotor operating with single and two-phase air-water flows. Different liquid and gas flow rates, as well as different rotating speeds, were tested. Results have shown that the liquid velocity presented slight changes, whereas the turbulent kinetic energy and the turbulent shear stress increased for a small gas volume fraction. However, increasing the mean bubble diameter at the intake has reduced the turbulent kinetic energy. This effect could be due to the energy absorption on the surface of the bubbles. Moreover, the turbulent has increased by increasing the liquid flow rate while keeping the gas flow rate fixed. The findings from this work shed light on the gas-phase effect over the liquid flow field, especially on bubble-induced turbulence. Furthermore, the results presented herein can be useful for numerical modeling validation and for improving models such as turbulence enhancement or suppression caused by bubbles.
引用
收藏
页数:26
相关论文
共 50 条
  • [21] Laser-induced incandescence particle image velocimetry (LII-PIV) for two-phase flow velocity measurement
    Fan, Luming
    McGrath, Dante
    Chong, Cheng Tung
    Jaafar, Mohammad Nazri Mohd
    Zhong, Hongtao
    Hochgreb, Simone
    EXPERIMENTS IN FLUIDS, 2018, 59 (10)
  • [22] Laser-induced incandescence particle image velocimetry (LII-PIV) for two-phase flow velocity measurement
    Luming Fan
    Dante McGrath
    Cheng Tung Chong
    Mohammad Nazri Mohd Jaafar
    Hongtao Zhong
    Simone Hochgreb
    Experiments in Fluids, 2018, 59
  • [23] Analysis of the cavitating draft tube vortex in a francis turbine using particle image velocimetry measurements in two-phase flow
    Iliescu, Monica Sanda
    Ciocan, Gabriel Dan
    Avellan, Francois
    JOURNAL OF FLUIDS ENGINEERING-TRANSACTIONS OF THE ASME, 2008, 130 (02): : 0211051 - 02110510
  • [24] Investigation of turbulence influence on the particle resistance in a two-phase flow
    Khil'kevich V.Ya.
    Sharov M.S.
    Russ. Aeronaut., 2008, 4 (388-395): : 388 - 395
  • [25] Particle sizing using particle imaging velocimetry for two-phase flows
    Kadambi, JR
    Martin, WT
    Amirthaganesh, S
    Wernet, MP
    POWDER TECHNOLOGY, 1998, 100 (2-3) : 251 - 259
  • [26] Investigation of the Taylor-Culick Flow Through Particle Image Velocimetry and Numerical Simulation
    Laboureur, D.
    Toth, B.
    Anthoine, J.
    AIAA JOURNAL, 2010, 48 (06) : 1077 - 1084
  • [27] Two-zone analysis of wavy two-phase flow using micro-particle image velocimetry (micro-PIV)
    Schubring, D.
    Foster, R. E.
    Rodriguez, D. J.
    Shedd, T. A.
    MEASUREMENT SCIENCE AND TECHNOLOGY, 2009, 20 (06)
  • [28] Investigation of the flow patterns and mixing efficiency in a stirred tank through particle image velocimetry
    Ciou, Zih-Yen
    Wu, Chih-Yung
    JOURNAL OF THE TAIWAN INSTITUTE OF CHEMICAL ENGINEERS, 2023, 149
  • [29] Particle Image Velocimetry Investigation of the Leakage Flow Through Clearance Gaps in Cambered Hydrofoils
    Chitrakar, Sailesh
    Neopane, Hari Prasad
    Dahlhaug, Ole Gunnar
    JOURNAL OF FLUIDS ENGINEERING-TRANSACTIONS OF THE ASME, 2017, 139 (09):
  • [30] Investigation and visualization of internal flow through particle aggregates and microbial flocs using particle image velocimetry
    Xiao, Feng
    Lam, Kit Ming
    Li, Xiao-yan
    JOURNAL OF COLLOID AND INTERFACE SCIENCE, 2013, 397 : 163 - 168