Numerical Simulation and Experimental Study on Dynamic Characteristics of Gas Turbine Rotor System Subjected to Ship Hull Excitation

被引:1
|
作者
Zhang, Xin [1 ]
Liu, Yongbao [1 ]
Wang, Qiang [1 ]
Xing, Zhikai [1 ]
Li, Mo [1 ]
机构
[1] Naval Univ Engn, Coll Power Engn, Wuhan 430033, Peoples R China
关键词
turbine rotor system; wave load; vibration transmission model; dynamic characteristics;
D O I
10.3390/pr12102091
中图分类号
TQ [化学工业];
学科分类号
0817 ;
摘要
To address the challenge of measuring the dynamic characteristic parameters of the gas turbine rotor system affected by hull excitation, a vibration transmission model integrating a ship model slice, test data, and a three-dimensional entity is proposed, based on the two-dimensional slice theory, scaled ship model, and finite element model of the turbine rotor system. The transient dynamic responses of the front and rear bearing points were calculated and analyzed. Vibration response tests with significant wave heights of 0.5 m, 1.25 m, 2.5 m, and 4 m were carried out in the towing tank of the ship model to obtain the dynamic characteristic parameters of the deck position. Techniques including wavelet denoising, Fast Fourier Transform (FFT), and signal resampling were employed to filter out and reconstruct high-frequency noise, overcoming the technical challenges of a high sampling frequency and a low computational efficiency. The experimental data and simulation results were compared and analyzed, validating the accuracy of the vibration transmission model of the turbine rotor system with data and entity integration. By comparing the vibration signal values in the X and Z directions at the front and rear bearing points after vibration transmission, it is evident that the effective values of the vibration signals at the front bearing point are 0.03% to 0.1% greater than those at the rear bearing point. This model provides a theoretical basis and reference for the design of the gas turbine rotor system.
引用
收藏
页数:19
相关论文
共 50 条
  • [31] Numerical Simulation of Flow Characteristics in High Pressure Disk Cavity System of Gas Turbine
    Mi, Hongbo
    Ren, Xiaodong
    Niu, Xiying
    Hu, Bo
    Gu, Chunwei
    Kung Cheng Je Wu Li Hsueh Pao/Journal of Engineering Thermophysics, 2023, 44 (06): : 1528 - 1537
  • [32] Numerical Simulation of the fogging System Location and Geometry on the Characteristics of Inlet Air to a Gas Turbine
    Babaei, M. A.
    Darbandi, M.
    Schneider, Gerry E.
    AIAA SCITECH 2024 FORUM, 2024,
  • [33] Experimental and numerical simulation study on the dynamic fracture of coal by gas expansion
    Wang, Qifei
    Zhao, Yuechao
    Li, Chengwu
    Xie, Beijing
    Xue, Honglai
    ENERGY SCIENCE & ENGINEERING, 2020, 8 (09) : 3047 - 3059
  • [34] Numerical simulation study on the damage characteristics of ship structures subjected to annular-shaped charge explosion
    Yanchao Guo
    Renshu Yang
    Suping Peng
    Journal of the Brazilian Society of Mechanical Sciences and Engineering, 2023, 45
  • [35] SIMULATION ON THE DYNAMIC BEHAVIOR OF THE PROPULSION SYSTEM SUBJECTED BY HULL DEFORMATION FOR LARGE VESSELS
    Tian, Zhe
    Yan, Xinping
    Zhang, Cong
    Tan, Weizhong
    PROCEEDINGS OF THE ASME 34TH INTERNATIONAL CONFERENCE ON OCEAN, OFFSHORE AND ARCTIC ENGINEERING, 2015, VOL 3, 2015,
  • [36] Numerical simulation study on the damage characteristics of ship structures subjected to annular-shaped charge explosion
    Guo, Yanchao
    Yang, Renshu
    Peng, Suping
    JOURNAL OF THE BRAZILIAN SOCIETY OF MECHANICAL SCIENCES AND ENGINEERING, 2023, 45 (12)
  • [37] Experimental and Numerical Study on the Effect of Corrosion on the Fatigue Behavior of a Marine Ship Hull
    Abdul-Hamied, Abdul-Hamied Ayad
    Assi, Abdullah Dhayea
    JOURNAL OF FAILURE ANALYSIS AND PREVENTION, 2024, 24 (03) : 1453 - 1462
  • [38] Computer simulation of complex ship system gas turbine - Synhronous generator
    Munitic, A
    Orsulic, M
    Dvornik, J
    1st International Industrial Simulation Conference 2003, 2003, : 192 - 196
  • [39] Characteristics and consequences of vortex wandering around a ship hull at drift: a numerical study
    Feder, Dag-Frederik
    Shevchuk, Ivan
    Sahab, Ahmed
    Abdel-Maksoud, Moustafa
    OCEAN ENGINEERING, 2022, 255
  • [40] Numerical Simulation and Experimental Study of the Rotor-Stator Interaction of a Turbine Under Variable Flow Coefficients
    Ren, Ran
    Du, Qiang
    Liu, Guang
    Lian, Zengyan
    Xie, Lei
    Luo, Yifu
    JOURNAL OF MARINE SCIENCE AND APPLICATION, 2024,