user

Analysis on inertia effect of carbon dioxide dry gas seal at high speed and pressure under laminar condition

被引：0
|
作者：
Xu H. [1 ,2 ]
Song P. [1 ,2 ]
Mao W. [2 ]
Deng Q. [2 ]
Sun X. [2 ]
机构：
[1] Faculty of Environmental Science and Engineering, Kunming University of Science and Technology, Kunming, 650500, Yunnan
[2] Faculty of Chemical Engineering, Kunming University of Science and Technology, Kunming, 650500, Yunnan
来源：
Huagong Xuebao/CIESC Journal | 2018年 / 69卷 / 10期
关键词：
Carbon dioxide; Inertia effect; Laminar; Numerical analysis; Real gas; Spiral groove dry gas seal;
D O I：
10.11949/j.issn.0438-1157.20180418
中图分类号：
学科分类号：
摘要：
The real gas property of carbon dioxide was expressed by third term virial equation, both the choked flow effect and the variation of gas viscosity were taken into account, the influence of inertia effect on the steady characteristics of pumping-inward and pumping-outward spiral groove dry gas seal (S-DGS) under laminar condition have been numerically investigated by referencing the theory of gas thrust bearing which considering inertia effect. Compared with the assumptions of ideal gas and inertialess, the results show that inertia effect induce a stronger influence on carbon dioxide real gas S-DGS. Inertia effect reduced leakage rate and opening force of pumping-inward S-DGS but the opposite was obtained for pumping-outward S-DGS. Taken pumping-inward SDGS as example, the influence of inertia effect on the steady characteristics of carbon dioxide S-DGS (i.e. leakage rate and opening force ) gradually enhanced with the increase of sealed gas pressure and rotational speed, while it being weaken with increased gas film thickness. The relative deviations of leakage rate and opening force caused by the inertia effect are 62.21% and 35.03% when sealed gas pressure is 10 MPa, gas film thickness is 3μm and rotational speed is 20000 r•min1, and the critical entrance pressure which causes a choked flow at exit is improved. In addition, the closer the temperature of carbon dioxide is to its critical temperature, the more obvious the inertial effect is. © All Right Reserved.
引用
下载
收藏
页码：4311 / 4323
页数：12
相关论文
共 33 条
  • [11] Brunetiere N., Tournerie B., The effect of inertia on radial flows-application to hydrostatic seals, Journal of Tribology, 128, 3, pp. 566-574, (2006)
  • [12] Zhao Y., Wei C., Yuan S.H., Et al., Theoretical and experimental study of cavitation effects on the dynamic characteristic of spiralgroove rotary seals (SGRSs), Tribology Letters, 64, 3, (2016)
  • [13] Zuk J., Analysis of face deformation effects on gas film seal performance, ASLE Transactions, 16, 4, pp. 267-275, (1973)
  • [14] Thomas S., Brunetiere N., Toumerie B., Numerical modeling of high pressure gas face seals, Journal of Tribology, 128, 2, pp. 241-242, (2006)
  • [15] Thomas S., Brunetiere N., Toumerie B., Thermoelastohydrodynamic behavior of mechanical gas face seals operating at high pressure, Journal of Tribology, 129, 4, pp. 841-850, (2007)
  • [16] Fairuz Z.M., Jahn I., Performance of supercritical CO<sub>2</sub> dry gas seals near the critical point, ASME Turbo Expo 2016: Turbomachinery Technical Conference and Exposition, (2016)
  • [17] Fairuz Z.M., Jahn I., The influence of real gas effects on the performance of supercritical CO<sub>2</sub> dry gas seals, Tribology International, 102, pp. 333-347, (2016)
  • [18] Song P.Y., Hu X.P., Xu H.J., Effect of real gas on dynamic performance of T-groove dry gas seal, CIESC Journal, 65, 4, pp. 1344-1352, (2014)
  • [19] Song P.Y., Zhang S., Xu H.J., Analysis of performance of spiral groove dry gas seal considered effects of both real gas and slip flow, CIESC Journal, 67, 4, pp. 1405-1415, (2016)
  • [20] Deng C.X., Song P.Y., Ma A.L., Analysis of Joule-Thomson effect of real gas system sealed by dry gas, CIESC Journal, 67, 9, pp. 3833-3842, (2016)
1234