Sorption and permeation behaviors of a series of olefins and nitrogen through PDMS membranes

被引:57
|
作者
Choi, Seung-Hak
Kim, Jeong-Hoon [1 ]
Lee, Soo-Bok
机构
[1] Korea Univ Sci & Technol, Taejon 305333, South Korea
[2] KRICT, Div Adv Chem Technol, Interface Mat & Engn Lab, Taejon 305600, South Korea
关键词
permeation; sorption; polydimethylsiloxane; olefins; nitrogen;
D O I
10.1016/j.memsci.2007.04.022
中图分类号
TQ [化学工业];
学科分类号
0817 ;
摘要
We have prepared three polydirnethylsiloxane (PDMS) membranes by adjusting the mixing ratio of PDMS precursors-cross-linkable siloxane oligomer with vinyl groups and siloxane oligomer with silane groups-in the presence of Pt catalyst, and examined the separation performance of the resulting membranes for C2H4 and N-2. We have also investigated the sorption and permeation behavior of a series of olefins (e.g., C2H4, C3H6, and C4H8) and nitrogen (N2) over a pressures range of 1-20 atm and a temperature range of -20 to 50 degrees C with the PDMS membranes prepared from the mixing ratio of 10: 1. It was found that the solubility of olefins and their solubility selectivity over nitrogen were influenced strongly by the critical temperatures of the permeating gases and were enhanced greatly by increasing pressure or decreasing temperature. The permeability of olefins and their perm-selectivity over nitrogen in PDMS membranes showed critical-temperature-dependent rather than size-dependent order, over the operational ranges of pressure and temperature. With increasing feed pressure and/or decreasing temperature, the permeability of more condensable olefin gases increased, but nitrogen permeability changed only slightly and thus, olefin/nitrogen selectivity increased greatly. (c) 2007 Elsevier B.V. All rights reserved.
引用
收藏
页码:54 / 62
页数:9
相关论文
共 50 条
  • [1] Permeation, sorption and diffusion behaviors of olefins and nitrogen through PDMS dense membrane
    Kim, J
    Shin, H
    Choi, S
    Park, I
    Lee, S
    [J]. FRONTIERS ON SEPARATION SCIENCE AND TECHNOLOGY, 2004, : 621 - 624
  • [2] Pervaporation separation of PDMS membranes and analysis of their permeation behaviors
    Zhao, Changwei, Jr.
    Li, Jiding, Sr.
    Zhao, Zhiping, Sr.
    Chen, Cui-Xian
    [J]. ABSTRACTS OF PAPERS OF THE AMERICAN CHEMICAL SOCIETY, 2005, 230 : U3782 - U3783
  • [3] Removal of trace VOCs from water through PDMS membranes and analysis of their permeation behaviors
    Yeom, CK
    Kim, HK
    Rhim, JW
    [J]. JOURNAL OF APPLIED POLYMER SCIENCE, 1999, 73 (04) : 601 - 611
  • [4] PERMEATION AND SORPTION FOR OXYGEN AND NITROGEN INTO POLYIMIDE MEMBRANES
    TOI, K
    SUZUKI, H
    IKEMOTO, I
    ITO, T
    KASAI, T
    [J]. JOURNAL OF POLYMER SCIENCE PART B-POLYMER PHYSICS, 1995, 33 (05) : 777 - 784
  • [5] Pervaporation permeation behavior of a series of chlorinated hydrocarbon/water mixtures through PDMS membranes
    Park, You-In
    Yeom, C. K.
    Lee, Sang-Hak
    Kim, Beom-Sik
    Lee, Jung-Min
    Joo, Hyeok-Jong
    [J]. JOURNAL OF INDUSTRIAL AND ENGINEERING CHEMISTRY, 2007, 13 (02) : 272 - 278
  • [6] Sorption, diffusion, and permeation of light olefins in poly(ether block amide) membranes
    Liu, Li
    Chakma, Amit
    Feng, Xianshe
    [J]. CHEMICAL ENGINEERING SCIENCE, 2006, 61 (18) : 6142 - 6153
  • [7] PERMEATION OF OXYGEN, ARGON AND NITROGEN THROUGH POLYMER MEMBRANES
    HARAYA, K
    HWANG, ST
    [J]. JOURNAL OF MEMBRANE SCIENCE, 1992, 71 (1-2) : 13 - 27
  • [8] PERMEATION AND SORPTION IN INHOMOGENEOUS POLYMER MEMBRANES
    FRISCH, HL
    [J]. POLYMER ENGINEERING AND SCIENCE, 1977, 17 (02): : 81 - 84
  • [9] SEPARATION OF PROPANE FROM PROPANE/NITROGEN MIXTURES USING PDMS COMPOSITE MEMBRANES BY VAPOR PERMEATION
    Cao, Jian-hua
    Lin, Yang-zheng
    Li, Ji-ding
    Chen, Cui-xian
    [J]. CHINESE JOURNAL OF POLYMER SCIENCE, 2009, 27 (05) : 621 - 627
  • [10] SEPARATION OF PROPANE FROM PROPANE/NITROGEN MIXTURES USING PDMS COMPOSITE MEMBRANES BY VAPOR PERMEATION
    李继定
    [J]. Chinese Journal of Polymer Science, 2009, 27 (05) : 621 - 627