A solution-processed silicon oxide gate dielectric prepared at a low temperature via ultraviolet irradiation for metal oxide transistors

A facile route for the preparation of a solution-processed silicon oxide dielectric from perhydropolysilazane (PHPS) at a low temperature (<= 150 degrees C) is proposed. Deep ultraviolet (DUV) irradiation on the PHPS-derived silicon oxide film, where the coupling agent of vinyltriethoxysilane (VTES) was introduced to assist the formation of the Si-O lattice network at a low temperature, allowed the prepared silicon oxide film to have device-quality insulating properties. The metal/insulator/metal capacitor with DUV-annealed silicon oxide exhibited a low gate leakage current density of 7.0 x 10 (8) A cm (2) at 1 MV cm (1), which was attributed to the photon-assisted purification and densification of the silicon oxide film. The suitability of this silicon oxide film as a gate insulator was evaluated in all-solution-processed indium zinc oxide (IZO) thin-film transistors (TFTs). The IZO TFTs that were fabricated at a contact annealing temperature of 150 degrees C exhibited a high field-effect mobility of 17.3 cm(2) V (-1) s (-1), a threshold voltage of 2.7 V, and an I-ON/OFF modulation ratio of 1 x 10(5). Therefore, DUV-assisted IZO TFTs with a PHPS-derived silicon oxide insulator are promising candidates for low-temperature, large-area, and flexible electronics for use on inexpensive plastic substrates.