EXPERIMENTAL STUDY ON HEAT TRANSFER BY GAS INJECTION IN THE PREHEATING ZONE OF A CONTINUOUS REHEATING FURNACE.

被引：0

作者：

Liu Renda ^{[1
]}

Yang Shaojl ^{[1
]}

机构：

[1] Chongqing Univ, China, Chongqing Univ, China

来源：

Kang T'ieh/Iron and Steel (Peking) | 1986年 / 21卷 / 12期

关键词：

ENERGY CONSERVATION - HEAT TRANSFER - Gases;

D O I：

暂无

中图分类号：

学科分类号：

摘要：

In order to recover the heat from low-temperature flue gas in the pusher-type reheating furnace, setting an injection device in the preheating zone was proposed to improve convection heat transfer. Good results have been obtained in the laboratory simulating hot injection. The mean heat flux and total heat transfer coefficient can be increased by 26% and 52-66%, respectively, under the following conditions: temperature in furnace at approximately 750-950 degree C, and temperature of injected gas at 370 degree C.

引用

页码：33 / 36

共 50 条

[1] EXPERIMENTAL RESULTS ON SCRAP PREHEATING BY SHOOTER TYPE FURNACE.
Narasaki, Seiji
Kawaguchi, Masanori
Ito, Takahiro
Transactions of the Iron and Steel Institute of Japan, 1985, 26 (02)
[2] INTENSIFICATION OF HEAT TRANSFER IN MULTI-ZONE CONTINUOUS REHEATING FURNACES FIRED WITH NATURAL GAS
ZARZHITS.YA
STAL IN ENGLISH-USSR, 1968, (07): : 618 - &
[3] EXPERIMENTAL STUDY OF THE SAFE INJECTION OF BITUMINOUS COAL INTO THE BLAST FURNACE.
Jing Dingzhong
Kang T'ieh/Iron and Steel (Peking), 1982, 17 (01): : 5 - 9
[4] ANALYSIS OF THE COMBUSTION ZONE IN AN EXPERIMENTAL BLAST FURNACE.
Hatano, Michiharu
Hiraoka, Bunsho
Fukuda, Mitsuichiro
Masuike, Tamotsu
Tetsu-To-Hagane/Journal of the Iron and Steel Institute of Japan, 1976, 62 (05): : 505 - 513
[5] DEVELOPMENT OF REHEATING FURNACE WITH WASTE GAS JET PREHEATING EQUIPMENT.
Fukuhisa, Yozo
Yamasaki, Jiro
Nakama, Akihiro
Okuno, Ryuzo
Minami, Syozo
1978, 64 (13): : 1996 - 2005
[6] Study and Evaluation of the Gas Dynamic Regime in the Lower Zone of a Blast Furnace.
Petrenko, V.A.
Kovshov, V.N.
Egorov, N.A.
Dyshlevich, I.I.
Gladkov, N.A.
Vereshchak, V.I.
1600,
[7] HEAT TRANSFER INTENSIFICATION IN THE VACUUM AIR FURNACE.
Boyarshinov, V.A.
Gotin, V.N.
Proceedings of the Society of Photo-Optical Instrumentation Engineers, 1979,
[8] TWO-DIMENSIONAL SIMULATION ON THE GAS FLOW AND HEAT TRANSFER IN THE BLAST FURNACE.
Yagi, Jun-ichiro
Takeda, Kanji
Omori, Yasuo
Biomedical Engineering (New York) (English translation of Meditsinskaya Tekhnika), 1980, 2
[9] GAS FLOW THROUGH COHESIVE ZONE OF BLAST FURNACE.
Propster, M.A.
Szekely, J.
Ironmaking and Steelmaking, 1979, 6 (05): : 209 - 220
[10] DEVELOPMENT OF SLAB REHEATING FURNACE WITH WASTE-GAS JET PREHEATING EQUIPMENT
FUKUHISA, Y
YAMASAKI, J
NAKAMA, A
OKUNO, R
MINAMI, S
TRANSACTIONS OF THE IRON AND STEEL INSTITUTE OF JAPAN, 1980, 20 (07) : 476 - 485

← 1 2 3 4 5 →