Experimental study of the steady and dynamic efficiencies of a solar methanol steam reforming reactor filled with a phase change material for hydrogen production

被引：0
|
作者：
Ma Z. [1 ]
Cheng Z. [1 ]
He Y. [1 ]
机构：
[1] Key Laboratory of Thermo-Fluid Science and Engineering of Ministry of Education, School of Energy and Power Engineering, Xi'an Jiaotong University, Xi'an
来源：
Qinghua Daxue Xuebao/Journal of Tsinghua University | 2021年 / 61卷 / 12期
关键词：
Dynamic operation; Phase change material; Solar methanol steam reforming reactor; Solar thermochemical reaction;
D O I：
10.16511/j.cnki.qhdxxb.2021.25.002
中图分类号：
学科分类号：
摘要：
Solar thermochemical reactors are a promising way to produce clean hydrogen energy. However, the operation of a reactor driven by solar irradiation will fluctuate as the solar irradiation changes. This study analyzed the thermal management of a solar methanol steam reforming reactor for hydrogen production with phase change material (PCM) in the reactor. The analyses considered two latent heat type thermochemical reactors. The thermal and hydrogen production characteristics of these thermochemical reactors were investigated experimentally to show the influence of the heat flux variations. Then, the models were used to study the effect of the phase change material position on the reactor hydrogen production. Finally, the dynamic efficiencies of the latent heat type reactors were compared with that of the original design to show that when the reactor surface heat flux reaches 7 kW/m2, the H2 proportion of the production rate is 0.713 and the methanol conversion efficiency is 0.956. Increasing the heat flux increases the methanol conversion efficiency. Adding the PCM in the shell reduces the required catalyst mass by 66.0% while adding the PCM in the tube side reduces the required catalyst mass by 13.5% for steady-state operation while the reactor continues to operate efficiently. For dynamic operation, the methanol conversion efficiency is reduced by 23.4% when the PCM is added to the shell side and by 13.7% when the PCM is added to the tube side while the reactor thermal inertia is improved to cope with sudden heat flux changes. © 2021, Tsinghua University Press. All right reserved.
引用
收藏
页码：1371 / 1378
页数：7
相关论文
共 18 条
  • [1] REAL D, DUMANYAN I, HOTZ N., Renewable hydrogen production by solar-powered methanol reforming, International Journal of Hydrogen Energy, 41, 28, pp. 11914-11924, (2016)
  • [2] CHENG Z D, MEN J J, ZHAO X R, Et al., A comprehensive study on parabolic trough solar receiver-reactors of methanol-steam reforming reaction for hydrogen production, Energy Conversion and Management, 186, pp. 278-292, (2019)
  • [3] HE Y L, WANG K, QIU Y, Et al., Review of the solar flux distribution in concentrated solar power: Non-uniform features, challenges, and solutions, Applied Thermal Engineering, 149, pp. 448-474, (2019)
  • [4] HONG H, JIN H G, JI J, Et al., Solar thermal power cycle with integration of methanol decomposition and middle-temperature solar thermal energy, Solar Energy, 78, 1, pp. 49-58, (2005)
  • [5] LIU Q B, HONG H, YUAN J L, Et al., Experimental investigation of hydrogen production integrated methanol steam reforming with middle-temperature solar thermal energy, Applied Energy, 86, 2, pp. 155-162, (2009)
  • [6] HONG H, LIU Q B, JIN H G., Operational performance of the development of a 15 kW parabolic trough mid-temperature solar receiver/reactor for hydrogen production, Applied Energy, 90, 1, pp. 137-141, (2012)
  • [7] CHENG Z D, HE Y L, CUI F Q., Numerical study of heat transfer enhancement by unilateral longitudinal vortex generators inside parabolic trough solar receivers, International Journal of Heat and Mass Transfer, 55, 21-22, pp. 5631-5641, (2012)
  • [8] WANG Y J, LIU Q B, SUN J, Et al., A new solar receiver/reactor structure for hydrogen production, Energy Conversion and Management, 133, pp. 118-126, (2017)
  • [9] ZHENG Z J, HE Y, HE Y L, Et al., Numerical optimization of catalyst configurations in a solar parabolic trough receiver-reactor with non-uniform heat flux, Solar Energy, 122, pp. 113-125, (2015)
  • [10] LIU Y, CHEN Q, HU K, Et al., Porosity distribution optimization catalyst for methanol decomposition in solar parabolic trough receiver-reactors by the variational method, Applied Thermal Engineering, 129, pp. 1563-1572, (2018)
12