Research on the cook-off characteristics of DNAN explosive

被引：0
|
作者：
Chen L. [1 ]
Li B.-B. [1 ]
Ma X. [1 ]
机构：
[1] State Key Laboratory of Explosion Science and Technology, Beijing Institute of Technology, Beijing
来源：
Hanneng Cailiao/Chinese Journal of Energetic Materials | 2016年 / 24卷 / 01期
关键词：
2,4-dinitroanisole (DNAN); Fused cast explosive; Numerical simulation; Phase transition;
D O I：
10.11943/j.issn.1006-9941.2016.01.004
中图分类号：
学科分类号：
摘要：
Fused cast explosive will melt in the process of cook-off, which will affect the thermal reaction of the explosive. In this paper, the cook-off bomb test of carrier explosive 2,4-dinitroanisole (DNAN) was carried out to measure the temperature change in the explosive center point and observe the melting and reaction situation of explosive. A thermal reaction model of fused cast explosive was established. The melting process of explosive was calculated and analyzed by an enthalpy-porosity method. The autothermic reaction process, thermal conduction, convection after explosive melting and radiation heat transfer of air were considered. The numerical simulations of the explosive cook-off test was performed. Compared with the experimental results, the accuracy of the calculation was verified. The activation energy and pre-exponential (frequency) factor of DNAN explosive were 172 kJ·mol-1 and 1.20×1011 s-1, respectively. The cook-off characteristics of DNAN were calculated and analyzed at six kinds of heating rates of 3.3 K·h-1, 0.3 K·min-1, 1.0 K·min-1, 3.0 K·min-1, 10 K·min-1 and 60 K·min-1. The explosive at slow heating rate completely melted before ignition. And the explosive at relativly fast heating rate ignited on the edge, while the explosive inside not completely melted. The images of temperature distribution and liquid phase fraction distribution of ignition time were obtained. Results show that in the cook-off of fused cast explosive, the state of the explosive before ignition will be affected by heating rates, and the intensity of explosive thermal reaction will be affected by that. © 2016, Editorial Board of Chinese Chinese Journal of Energetic Materials. All right reserved.
引用
收藏
页码：27 / 32
页数：5
相关论文
共 10 条
  • [1] Scholtes J.H.G., Vander Meer B.J., Temperature and Strain Gauge Measurements in the TNO-PML Cook-off Test, (1996)
  • [2] McCallen R., Dunn T., Nichols A., Et al., Modeling of thermal convection of liquid TNT for Cook-off, Nuclear Explosives Code Development Conference, (2002)
  • [3] Chen L., Wang P., Feng C.-G., Numerical simulation of cook-off about phase transition of explosive, Chinese Journal of Energetic Materials (Hanneng Cailiao), 17, 5, pp. 568-573, (2009)
  • [4] Wang H.-X., Wang X.-F., Luo Y.-M., Cook-off experiment of DNAN, Chinese Journal of Energetic Materials (Hanneng Cailiao), 17, 2, pp. 183-186, (2009)
  • [5] Jones D.A., Parker R.P., Heat Flow Calculations for the Small-scale Cook-off Bomb Test, (1991)
  • [6] Wang F.-J., Analysis of Computational Fluid Dynamics, (2004)
  • [7] Wang P., Chen L., Wang Y., Et al., Numerical simulation of explosive cook-off at different heating rate, 2007 International Autumn Seminar on Propellants, Explosives and Pyrotechnics (2007IASPEP)
  • [8] Ma X., Research on thethermal reaction characteristics and rules of high mixed explosives, (2014)
  • [9] Fluent Inc., FLUENT User's Guide, (2006)
  • [10] Roduit B., Borgeat C., Berger B., Et al., Up-scaling of DSC data of high energetic materials simulation of cook-off experiments, Journal of Thermal Analysis and Calorimetry, 85, 1, pp. 195-202, (2006)
1