VFAs Production Technology by Two-stage Fermentation from Rice Straw Based on Digestate Reuse

被引：0

作者：

Ai P. ^{[1
,2
]}

Tian Q. ^{[3
]}

Xi J. ^{[2
]}

Mei Z. ^{[2
]}

Yan S. ^{[1
]}

Fan Q. ^{[1
]}

机构：

[1] College of Engineering, Huazhong Agricultural University, Wuhan

[2] Key Laboratory of Development and Application of Rural Renewable Energy, Ministry of Agriculture and Rural Affairs, Chengdu

[3] Hangzhou Energy Environment Engineering Co., Ltd., Hangzhou

来源：

Nongye Jixie Xuebao/Transactions of the Chinese Society for Agricultural Machinery | 2019年 / 50卷 / 01期

关键词：

Anaerobic digestate; Anaerobic digestion; Rice straw; Volatile fatty acids;

D O I：

10.6041/j.issn.1000-1298.2019.01.032

中图分类号：

学科分类号：

摘要：

Volatile fatty acids (VFAs) production process via anaerobic digestion from rice straw is highly promising due to the preferable economic value of mixed short-chain fatty acids. However, the VFA fermentation has critical disadvantage as low digestion rate of rice straw owing to the relatively short digestion time. To increase the VFAs yield and enhance rice straw utilization, the anaerobic digestion (AD) digestate from the VFAs production was exploited for the second stage VFAs production. The first stage VFAs production was conducted by three different pretreatment methods and three different fermentation temperatures, thus the AD digestate of all sets after fermentation was used as substrates for the second stage VFAs production, and VFAs potential production for all AD digestate sets still needed to be investigated. The AD digestate of all sets was directly fermented at the same temperature of 35℃ for the second stage VFAs production without further additional pretreatment. The results revealed that all sets can have more stable and suitable pH value at the second stage. Both hydrothermal and 2% HCl sets had higher VFAs yield at the second stage. The maximum VFAs yield was achieved under the condition of 1% Ca(OH)2 pretreatment and temperature of 35℃. By combining the two stages together, the total VFAs yield of 1% Ca(OH)2 group was enhanced from 0.07~0.20 g/g at the first stage to 0.27~0.38 g/g in total. The mass balance analysis was based on the hypotheses that the initial substrate was 100 g rice straw and 1% Ca(OH)2 pretreatment was chosen at the first stage. The 1% Ca(OH)2 and 35℃ group produced 12.24 g VFAs at the first stage and 11.69 g VFAs at the second stage. The VFAs yield for the combined two-stage was 95.5% greater than that of the first stage. The research result could provide useful reference for enhancing VFAs yield by further fermentation of the AD digestate obtained from the first stage. © 2019, Chinese Society of Agricultural Machinery. All right reserved.

引用

页码：292 / 298

页数：6

共 18 条

[1] Deng Y., Huang Z., Ruan W., Et al., Effect of digestate recirculation ratio and organic loading rate on fermentation characteristics for anaerobic digestion of straw, Transactions of the Chinese Society for Agricultural Machinery, 47, 11, (2016)
[2] Li W., Wu S., Hamidom B., Et al., Status analysis and development prospect of biogas engineering technology, Transactions of the Chinese Society for Agricultural Machinery, 46, 7, pp. 187-196, (2015)
[3] Ai P., Tian Q., Xi J., Et al., Enhancement of volatile fatty acids production from rice straw via anarobic digestion with different pretreatment, Transactions of the Chinese Society for Agricultural Machinery, 49, 3, pp. 309-316, (2018)
[4] Cai M., Hong C., Zhao Q., Et al., Optimal production of polyhydroxyalkanoates (PHA) in activated sludge fed byvolatile fatty acids (VFAs) generated from alkaline excess sludge fermentation, Bioresource Technology, 100, 3, pp. 1399-1405, (2009)
[5] Li J., Wei L., Duan Q., Et al., Semi-continuous anaerobic co-digestion of dairy manure with three crop residues for biogas production, Bioresource Technology, 156, 6, pp. 307-313, (2014)
[6] Wang D., Ai P., Yan L., Et al., Research on ethanol production of anaerobic digestion fiber from rice straw, Transactions of the Chinese Society for Agricultural Machinery, 46, 5, pp. 156-163, (2015)
[7] Lepisto R., Rintala J., Conversion of volatile fatty acids in an extreme thermophilic (76~80℃) upflow anaerobic sludgeblanket reactor, Bioresource Technology, 56, 2, pp. 221-227, (1996)
[8] Peces M., Astals S., Clarke W.P., Et al., Semi-aerobic fermentation as a novel pre-treatment to obtain VFA and increase methane yield from primary sludge, Bioresource Technology, 200, 2, pp. 631-638, (2016)
[9] Lee M., Hidaka T., Tsuno H., Two-phased hyperthermophilic anaerobic co-digestion of waste activated sludge with kitchen garbage, Journal of Bioscience and Bioengineering, 108, 5, pp. 408-413, (2009)
[10] Hasyim R., Imai T., Reungsang A., Et al., Extreme-thermophilic biohydrogen production by an anaerobic heat treated digested sewage sludge culture, International Journal of Hydrogen Energy, 36, 14, pp. 8727-8734, (2011)

← 1 2 →